Manuals / Henny Penny / Kitchen Appliance / Fryer

Henny Penny OFE/OFG-342, OFE/OFG-341 Drain switch wired N/C, Model OFE/OFG/OEA/OGA-341,342, 2-34

Models: OEA/OGA-341 OEA/OGA-342 OFE/OFG-341 OFE/OFG-342

1 82

Download 82 pages 31.46 Kb

Page 44

Image 44

Model OFE/OFG/OEA/OGA-341, 342

Drain switch wired N/C

2-34

106

Page 44

Image 44

Henny Penny OFE/OFG-342, OFE/OFG-341, OEA/OGA-342 Drain switch wired N/C, Model OFE/OFG/OEA/OGA-341,342, 2-34

Contents

Henny Penny High Volume Open Fryer TECHNICAL MANUALModel OFE/OFG-341 Model OFE/OFG-342 Model OEA/OGA-341 Model OEA/OGA-342Model OFE/OFG/OEA/OGA-341,342 FM06-030 Revised Page TABLE OF CONTENTSSection SECTION 1. TROUBLESHOOTING 1-2.SAFETY1-1.INTRODUCTION injury1-3.TROUBLESHOOTING PROBLEMinjuries and/or property damage could result CAUSE1-3.TROUBLESHOOTINGContinued cleaning the fryerthoroughly PROBLEM1-2.TROUBLESHOOTING ContinuedPROBLEM CAUSE1-4.ERROR CODES DISPLAYPANEL BOARD CORRECTION CAUSE1-4.ERROR CODES ContinuedDISPLAY CAUSESECTION 2. MAINTENANCE MAINTENANCE HINTSHIGH TEMPERATURE INTRODUCTIONGas Units Continued and remove the high limit from bracketFigure Figure2-3.HIGH TEMPERATURE Replacementpower switch to OFF and disconnect main circuit power terminalsPANEL REPLACEMENT 2-5.POWER SWITCH2-4.COMPLETE CONTROL power switch to OFF and disconnect main circuit2-5.POWER SWITCH Continued FigureFigure Figure1.Remove electrical power supplied to the fryer ContinuedFigure Figure2-8.FLAME SENSOR/ PILOT / IGNITOR ASSEMBLY GAS Figure FigureFigure Figurepower switch to OFF and disconnect main circuit breaker, or unplug cord at wall receptacleFigure FigureREPLACEMENT 1. Remove electrical power supplied to the unit2-10.TRANSFORMER those components with low voltagepower switch to OFF and disconnect main circuit Figurebreaker, or unplug cord at wall receptacle Figure2-14.FILTER SWITCH REPLACEMENT1. Remove electrical power supplied to the unit FigurePROCEDURE, MOVE THE MAIN POWER SWITCH BOX OR UNPLUG SERVICE CORD FROM WALLTO AVOID PERSONAL INJURY OR PROPERTY DAMAGE, BEFORE STARTING THIS2-15.GAS CONTROL VALVE REPLACEMENT Continued FigureFigure Figure2-15.GAS CONTROL VALVE REPLACEMENT Continued power switch to OFF and disconnect main circuitFigure Figure2-16.BLOWER MOTOR REPLACEMENT Continued FigureFigure Figureunits will have power 2-16BLOWER MOTOR 2-17Wire Nos VoltageWattage Ohms coldCheckout Power Removed Heat Contactorunits will have power. Mercury2-18.HEATING CONTACTORS2-18.HEATING CONTACTORS ELECTRIC Continued Heat ContactorReplacement FigureFigure Replacement Primary Contactor 2-18.HEATING CONTACTORS ELECTRIC ContinuedFigure Figure2-19.SPEAKER ASSEMBLY power switch to OFF and disconnect main circuitFigure breaker, or unplug cord at wall receptaclepower switch to OFF and disconnect main circuit FigureCheckout breaker, or unplug cord at wall receptacle2-20.HIGH TEMPERATURE connect the two electrical wiresLIMIT CONTROL ELECTRIC Continued 1. Drain the shortening from the frypotterminals 2-20.HIGH TEMPERATURELIMIT CONTROL ELECTRIC Continued FigureMOTOR REMOVAL FigureFigure Figure2-21.FILTER PUMP AND MOTOR REMOVAL Continued 2-22.AUTOLIFTTRANSFORMER if applicable2-24.AUTOLIFT ACTUATOR MOTORREPLACEMENT power switch to OFF and disconnect main circuit2-24.AUTOLIFT ACTUATOR MOTOR REPLACEMENT if applicableFigure Figure10. Install new actuator in reverse order 2-24.AUTOLIFT ACTUATOR MOTOR REPLACEMENTif applicable Figure2-31 Drain switch wired N/CModel OFE/OFG/OEA/OGA-341,342 2-32 Drain switch wired N/CModel OFE/OFG/OEA/OGA-341,342 2-33 Drain switch wired N/CModel OFE/OFG/OEA/OGA-341,342 2-34 Drain switch wired N/CModel OFE/OFG/OEA/OGA-341,342 2-35 Drain switch wired N/CModel OFE/OFG/OEA/OGA-341,342 2-36 Drain switch wired N/CModel OFE/OFG/OEA/OGA-341,342 2-37 Drain switch wired N/CModel OFE/OFG/OEA/OGA-341,342 2-38 Drain switch wired N/CModel OFE/OFG/OEA/OGA-341,342 2-39 Drain switch wired N/OModel OFE/OFG/OEA/OGA-341,342 2-40 Drain switch wired N/OModel OFE/OFG/OEA/OGA-341,342 2-41 Drain switch wired N/OModel OFE/OFG/OEA/OGA-341,342 2-42 Drain switch wired N/OModel OFE/OFG/OEA/OGA-341,342 2-43 Drain switch wired N/OModel OFE/OFG/OEA/OGA-341,342 2-44 Drain switch wired N/OModel OFE/OFG/OEA/OGA-341,342 2-45 Drain switch wired N/OModel OFE/OFG/OEA/OGA-341,342 2-46 Drain switch wired N/OModel OFE/OFG/OEA/OGA-341,342 3-3.WHEN ORDERING 3.6 WARRANTYSECTION 3. PARTS INFORMATION 3-1.INTRODUCTIONItem No Part NoDescription Qty. per WellGas Components Item NoPart No DescriptionGas Burner Assembly Item NoPart No DescriptionElectric Components Item NoPart No DescriptionItem No Part NoDescription Qty. per WellModel OFE/OFG/OEA/OGA-341,342 Qty. per Unit Item NoPart No DescriptionItem No Part NoDescription Qty. per UnitItem No Part NoDescription Qty. per UnitItem No Part NoDescription Qty. per WellItem No DescriptionQty. per Unit 33501Item No Part NoDescription Qty. per WellItem No Part NoDescription Qty. per WellItem No Part NoDescription Qty. per WellElectric Components Item NoPart No DescriptionOFG/OGA-341 OFG/OGA-342Item No DescriptionItem No Part NoDescription Qty. per WellDESCRIPTION OFG/OFE ELECTRO MECHANICAL PARTS LISTPART NUMBER Item No Description71899 Item NoDescription 341 DIRECT-CONNECTPARTS LIST Before March 1, 342 DIRECT-CONNECTPARTS LIST Before March 1,Part No DescriptionDescription Item NoPart No Part No DescriptionPart No DescriptionDescription Part No DescriptionModel OFE/OFG/OEA/OGA-341,342 3-26