Model OEA/OGA-341 Model OEA/OGA-342
Henny Penny High Volume Open Fryer
TECHNICAL MANUAL
Model OFE/OFG-341 Model OFE/OFG-342
Model OFE/OFG/OEA/OGA-341,342
FM06-030 Revised
Section
TABLE OF CONTENTS
Page
injury
SECTION 1. TROUBLESHOOTING
1-2.SAFETY
1-1.INTRODUCTION
CAUSE
1-3.TROUBLESHOOTING
PROBLEM
injuries and/or property damage could result
PROBLEM
1-3.TROUBLESHOOTINGContinued
cleaning the fryer
thoroughly
CAUSE
1-2.TROUBLESHOOTING
Continued
PROBLEM
CAUSE
1-4.ERROR CODES
DISPLAY
PANEL BOARD CORRECTION
CAUSE
1-4.ERROR CODES
Continued
DISPLAY
INTRODUCTION
SECTION 2. MAINTENANCE
MAINTENANCE HINTS
HIGH TEMPERATURE
Figure
Gas Units Continued
and remove the high limit from bracket
Figure
power terminals
2-3.HIGH TEMPERATURE
Replacement
power switch to OFF and disconnect main circuit
power switch to OFF and disconnect main circuit
PANEL REPLACEMENT
2-5.POWER SWITCH
2-4.COMPLETE CONTROL
Figure
2-5.POWER SWITCH Continued
Figure
Figure
Figure
1.Remove electrical power supplied to the fryer
Continued
Figure
2-8.FLAME SENSOR/ PILOT / IGNITOR ASSEMBLY GAS
Figure
Figure
Figure
Figure
Figure
power switch to OFF and disconnect main circuit
breaker, or unplug cord at wall receptacle
Figure
those components with low voltage
REPLACEMENT
1. Remove electrical power supplied to the unit
2-10.TRANSFORMER
Figure
power switch to OFF and disconnect main circuit
Figure
breaker, or unplug cord at wall receptacle
Figure
2-14.FILTER SWITCH
REPLACEMENT
1. Remove electrical power supplied to the unit
DAMAGE, BEFORE STARTING THIS
PROCEDURE, MOVE THE MAIN POWER SWITCH
BOX OR UNPLUG SERVICE CORD FROM WALL
TO AVOID PERSONAL INJURY OR PROPERTY
Figure
2-15.GAS CONTROL VALVE REPLACEMENT Continued
Figure
Figure
Figure
2-15.GAS CONTROL VALVE REPLACEMENT Continued
power switch to OFF and disconnect main circuit
Figure
Figure
2-16.BLOWER MOTOR REPLACEMENT Continued
Figure
Figure
2-17
units will have power
2-16
BLOWER MOTOR
Ohms cold
Wire Nos
Voltage
Wattage
CONTACTORS
Checkout Power Removed
Heat Contactorunits will have power. Mercury
2-18.HEATING
Figure
2-18.HEATING CONTACTORS ELECTRIC Continued
Heat Contactor
Replacement
Figure
Figure Replacement Primary Contactor
2-18.HEATING CONTACTORS ELECTRIC Continued
Figure
breaker, or unplug cord at wall receptacle
2-19.SPEAKER ASSEMBLY
power switch to OFF and disconnect main circuit
Figure
breaker, or unplug cord at wall receptacle
power switch to OFF and disconnect main circuit
Figure
Checkout
1. Drain the shortening from the frypot
2-20.HIGH TEMPERATURE
connect the two electrical wires
LIMIT CONTROL ELECTRIC Continued
Figure
terminals
2-20.HIGH TEMPERATURE
LIMIT CONTROL ELECTRIC Continued
Figure
MOTOR REMOVAL
Figure
Figure
if applicable
2-21.FILTER PUMP AND MOTOR REMOVAL Continued
2-22.AUTOLIFT
TRANSFORMER
power switch to OFF and disconnect main circuit
2-24.AUTOLIFT
ACTUATOR MOTOR
REPLACEMENT
Figure
2-24.AUTOLIFT ACTUATOR MOTOR REPLACEMENT
if applicable
Figure
Figure
10. Install new actuator in reverse order
2-24.AUTOLIFT ACTUATOR MOTOR REPLACEMENT
if applicable
Model OFE/OFG/OEA/OGA-341,342
Drain switch wired N/C
2-31
Model OFE/OFG/OEA/OGA-341,342
Drain switch wired N/C
2-32
Model OFE/OFG/OEA/OGA-341,342
Drain switch wired N/C
2-33
Model OFE/OFG/OEA/OGA-341,342
Drain switch wired N/C
2-34
Model OFE/OFG/OEA/OGA-341,342
Drain switch wired N/C
2-35
Model OFE/OFG/OEA/OGA-341,342
Drain switch wired N/C
2-36
Model OFE/OFG/OEA/OGA-341,342
Drain switch wired N/C
2-37
Model OFE/OFG/OEA/OGA-341,342
Drain switch wired N/C
2-38
Model OFE/OFG/OEA/OGA-341,342
Drain switch wired N/O
2-39
Model OFE/OFG/OEA/OGA-341,342
Drain switch wired N/O
2-40
Model OFE/OFG/OEA/OGA-341,342
Drain switch wired N/O
2-41
Model OFE/OFG/OEA/OGA-341,342
Drain switch wired N/O
2-42
Model OFE/OFG/OEA/OGA-341,342
Drain switch wired N/O
2-43
Model OFE/OFG/OEA/OGA-341,342
Drain switch wired N/O
2-44
Model OFE/OFG/OEA/OGA-341,342
Drain switch wired N/O
2-45
Model OFE/OFG/OEA/OGA-341,342
Drain switch wired N/O
2-46
3-1.INTRODUCTION
3-3.WHEN ORDERING
3.6 WARRANTY
SECTION 3. PARTS INFORMATION
Qty. per Well
Item No
Part No
Description
Description
Gas Components
Item No
Part No
Description
Gas Burner Assembly
Item No
Part No
Description
Electric Components
Item No
Part No
Qty. per Well
Item No
Part No
Description
Model OFE/OFG/OEA/OGA-341,342
Description
Qty. per Unit
Item No
Part No
Qty. per Unit
Item No
Part No
Description
Qty. per Unit
Item No
Part No
Description
Qty. per Well
Item No
Part No
Description
33501
Item No
Description
Qty. per Unit
Qty. per Well
Item No
Part No
Description
Qty. per Well
Item No
Part No
Description
Qty. per Well
Item No
Part No
Description
Description
Electric Components
Item No
Part No
Description
OFG/OGA-341
OFG/OGA-342
Item No
Qty. per Well
Item No
Part No
Description
PART NUMBER
OFG/OFE ELECTRO MECHANICAL PARTS LIST
DESCRIPTION
Description
Item No
Description
Item No
71899
Description
341 DIRECT-CONNECTPARTS LIST Before March 1,
342 DIRECT-CONNECTPARTS LIST Before March 1,
Part No
Part No
Item No
Description
Description
Part No
Description
Part No
Description
3-26
Part No
Description
Model OFE/OFG/OEA/OGA-341,342