Manuals / Henny Penny / Kitchen Appliance / Fryer

Henny Penny OEA/OGA-342 DIRECT-CONNECTPARTS LIST Before March 1, Part No, Description

Models: OEA/OGA-341 OEA/OGA-342 OFE/OFG-341 OFE/OFG-342

1 82

Download 82 pages 31.46 Kb

Page 78

Image 78

Model OFE/OFG/OEA/OGA-341, 342

341 DIRECT-CONNECT PARTS LIST (Before March 1, 2006)

Part No.	Description	Qty.
16282	NIPPLE 3/4 X CLOSE	1
21611	DISCONNECT-MALE	1
21612	DISCONNECT-FEMALE	1
21753	HOSE-SHORTENING DISCARD	1
21800	VALVE-3/4 CHECK	1
23430	VALVE-3/4 INLET-E34X	1
67850	BRACKET-34X D/C REAR SUPPORT	1
FP01-140	PLUG-3/4 PIPE-BI	2
FP01-142	CROSS-3/4 NPT BI	1
FP02-039	NIPPLE-3/4 X 6 LG-BI	1
FP02-059	NIPPLE-3/4 X 27 LG-BI	1
SC03-001	SCREW #10 X 1/2 PH PHD TEK 2 C	2
342 DIRECT-CONNECT PARTS LIST (Before March 1, 2006)
Part No.	Description	Qty.
16282	NIPPLE 3/4 X CLOSE	1
21611	DISCONNECT-MALE	1
21612	DISCONNECT-FEMALE	1
21753	HOSE-SHORTENING DISCARD	1
21800	VALVE-3/4 CHECK	1
67850	BRACKET-34X D/C REAR SUPPORT	1
FP02-059	NIPPLE-3/4 X 27 LG-BI	1
SC03-001	SCREW #10 X 1/2 PH PHD TEK 2 C	2
FP01-140	PLUG-3/4 PIPE-BI	1
FP02-033	NIPPLE-3/4 NPT X 4 IN LONG BI	1
FP02-039	NIPPLE-3/4 X 6 LG-BI	1

3-22

806

Page 78

Image 78

Henny Penny OEA/OGA-342, OFE/OFG-342, OFE/OFG-341, OEA/OGA-341 DIRECT-CONNECTPARTS LIST Before March 1, Part No, Description

Contents

Model OFE/OFG-341 Model OFE/OFG-342 Henny Penny High Volume Open FryerTECHNICAL MANUAL Model OEA/OGA-341 Model OEA/OGA-342Model OFE/OFG/OEA/OGA-341,342 FM06-030 Revised TABLE OF CONTENTS SectionPage 1-1.INTRODUCTION SECTION 1. TROUBLESHOOTING1-2.SAFETY injuryinjuries and/or property damage could result 1-3.TROUBLESHOOTINGPROBLEM CAUSEthoroughly 1-3.TROUBLESHOOTINGContinuedcleaning the fryer PROBLEMPROBLEM 1-2.TROUBLESHOOTINGContinued CAUSEPANEL BOARD CORRECTION 1-4.ERROR CODESDISPLAY CAUSEDISPLAY 1-4.ERROR CODESContinued CAUSEINTRODUCTION SECTION 2. MAINTENANCEMAINTENANCE HINTS HIGH TEMPERATUREFigure Gas Units Continuedand remove the high limit from bracket Figurepower terminals Replacementpower switch to OFF and disconnect main circuit 2-3.HIGH TEMPERATURE2-4.COMPLETE CONTROL PANEL REPLACEMENT2-5.POWER SWITCH power switch to OFF and disconnect main circuitFigure 2-5.POWER SWITCH ContinuedFigure FigureFigure 1.Remove electrical power supplied to the fryerContinued Figure2-8.FLAME SENSOR/ PILOT / IGNITOR ASSEMBLY GAS Figure FigureFigure Model OFE/OFG/OEA/OGA-341,342Figure power switch to OFF and disconnect main circuitbreaker, or unplug cord at wall receptacle Figure2-10.TRANSFORMER REPLACEMENT1. Remove electrical power supplied to the unit those components with low voltagebreaker, or unplug cord at wall receptacle power switch to OFF and disconnect main circuitFigure Figure1. Remove electrical power supplied to the unit 2-14.FILTER SWITCHREPLACEMENT FigureTO AVOID PERSONAL INJURY OR PROPERTY PROCEDURE, MOVE THE MAIN POWER SWITCHBOX OR UNPLUG SERVICE CORD FROM WALL DAMAGE, BEFORE STARTING THISFigure 2-15.GAS CONTROL VALVE REPLACEMENT ContinuedFigure FigureFigure 2-15.GAS CONTROL VALVE REPLACEMENT Continuedpower switch to OFF and disconnect main circuit breaker, or unplug cord at wall receptacleFigure 2-16.BLOWER MOTOR REPLACEMENT ContinuedFigure FigureBLOWER MOTOR units will have power2-16 2-17Wattage Wire NosVoltage Ohms cold2-18.HEATING Checkout Power RemovedHeat Contactorunits will have power. Mercury CONTACTORSReplacement 2-18.HEATING CONTACTORS ELECTRIC ContinuedHeat Contactor FigureFigure Figure Replacement Primary Contactor2-18.HEATING CONTACTORS ELECTRIC Continued FigureFigure 2-19.SPEAKER ASSEMBLYpower switch to OFF and disconnect main circuit breaker, or unplug cord at wall receptacleCheckout power switch to OFF and disconnect main circuitFigure breaker, or unplug cord at wall receptacleLIMIT CONTROL ELECTRIC Continued connect the two electrical wires2-20.HIGH TEMPERATURE 1. Drain the shortening from the frypotLIMIT CONTROL ELECTRIC Continued terminals2-20.HIGH TEMPERATURE FigureFigure MOTOR REMOVALFigure FigureTRANSFORMER 2-21.FILTER PUMP AND MOTOR REMOVAL Continued2-22.AUTOLIFT if applicableREPLACEMENT 2-24.AUTOLIFTACTUATOR MOTOR power switch to OFF and disconnect main circuitFigure 2-24.AUTOLIFT ACTUATOR MOTOR REPLACEMENTif applicable Figureif applicable 10. Install new actuator in reverse order2-24.AUTOLIFT ACTUATOR MOTOR REPLACEMENT FigureDrain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-31 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-32 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-33 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-34 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-35 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-36 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-37 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-38 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-39 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-40 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-41 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-42 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-43 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-44 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-45 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-46 SECTION 3. PARTS INFORMATION 3-3.WHEN ORDERING3.6 WARRANTY 3-1.INTRODUCTIONDescription Item NoPart No Qty. per WellPart No Gas ComponentsItem No DescriptionPart No Gas Burner AssemblyItem No DescriptionPart No Electric ComponentsItem No DescriptionDescription Item NoPart No Qty. per WellModel OFE/OFG/OEA/OGA-341,342 Part No Qty. per UnitItem No DescriptionDescription Item NoPart No Qty. per UnitDescription Item NoPart No Qty. per UnitQty. per Well Item NoDescription 60207Qty. per Unit Item NoDescription 33501Description Item NoPart No Qty. per WellDescription Item NoPart No Qty. per WellDescription Item NoPart No Qty. per WellPart No Electric ComponentsItem No DescriptionItem No OFG/OGA-341OFG/OGA-342 DescriptionDescription Item NoPart No Qty. per WellOFG/OFE ELECTRO MECHANICAL PARTS LIST PART NUMBERDESCRIPTION Item No DescriptionItem No Description71899 Part No 341 DIRECT-CONNECTPARTS LIST Before March 1,342 DIRECT-CONNECTPARTS LIST Before March 1, DescriptionItem No Part NoDescription Part No Part NoDescription DescriptionDescription Model OFE/OFG/OEA/OGA-341,342 Part NoDescription 3-26

341 DIRECT-CONNECT PARTS LIST (Before March 1, 2006)

342 DIRECT-CONNECT PARTS LIST (Before March 1, 2006)