Manuals / Henny Penny / Kitchen Appliance / Fryer

Henny Penny OEA/OGA-341 Ofg/Ofe Electro Mechanical Parts List, Part Number, Description

Models: OEA/OGA-341 OEA/OGA-342 OFE/OFG-341 OFE/OFG-342

1 82

Page 75

		Model OFE/OFG/OEA/OGA-341, 342
	OFG/OFE ELECTRO MECHANICAL PARTS LIST
PART NUMBER		DESCRIPTION
√	60816	Adjustable Relay Base
√	60817	Adjustable Time Delay Relay
√	60818	24VAC Coil Relay
√	60765	24V Dual Face Timer
√	14851	Thermostat Kit
√	60814	E/M Bulb Mounting Clip (Gas)
√	35916	Transformer 120V to 24V (Gas)
√	60536	Transformer 24V/230V (Electric)
√	60792	Indicator Light – 24 V
√	51795	24v Mechanical Contactor (Elec. Only)
√	65098	Assy. - Heat Contactor – 24V - CE
√	65567	Assy. – Timer Buzzer Coil-24V
	36224	Decal – E/M Controls – 34X

607

3-19

Page 75

Image 75

Henny Penny OEA/OGA-341, OFE/OFG-342, OFE/OFG-341 Ofg/Ofe Electro Mechanical Parts List, Part Number, Description

Contents

Model OEA/OGA-341 Model OEA/OGA-342 Henny Penny High Volume Open FryerTECHNICAL MANUAL Model OFE/OFG-341 Model OFE/OFG-342Model OFE/OFG/OEA/OGA-341,342 FM06-030 Revised TABLE OF CONTENTS SectionPage injury SECTION 1. TROUBLESHOOTING1-2.SAFETY 1-1.INTRODUCTIONCAUSE 1-3.TROUBLESHOOTINGPROBLEM injuries and/or property damage could resultPROBLEM 1-3.TROUBLESHOOTINGContinuedcleaning the fryer thoroughlyCAUSE 1-2.TROUBLESHOOTINGContinued PROBLEMCAUSE 1-4.ERROR CODESDISPLAY PANEL BOARD CORRECTIONCAUSE 1-4.ERROR CODESContinued DISPLAYINTRODUCTION SECTION 2. MAINTENANCEMAINTENANCE HINTS HIGH TEMPERATUREFigure Gas Units Continuedand remove the high limit from bracket Figurepower terminals 2-3.HIGH TEMPERATUREReplacement power switch to OFF and disconnect main circuitpower switch to OFF and disconnect main circuit PANEL REPLACEMENT2-5.POWER SWITCH 2-4.COMPLETE CONTROLFigure 2-5.POWER SWITCH ContinuedFigure FigureFigure 1.Remove electrical power supplied to the fryerContinued Figure2-8.FLAME SENSOR/ PILOT / IGNITOR ASSEMBLY GAS Figure FigureFigure FigureFigure power switch to OFF and disconnect main circuitbreaker, or unplug cord at wall receptacle Figurethose components with low voltage REPLACEMENT1. Remove electrical power supplied to the unit 2-10.TRANSFORMERFigure power switch to OFF and disconnect main circuitFigure breaker, or unplug cord at wall receptacleFigure 2-14.FILTER SWITCHREPLACEMENT 1. Remove electrical power supplied to the unitDAMAGE, BEFORE STARTING THIS PROCEDURE, MOVE THE MAIN POWER SWITCHBOX OR UNPLUG SERVICE CORD FROM WALL TO AVOID PERSONAL INJURY OR PROPERTYFigure 2-15.GAS CONTROL VALVE REPLACEMENT ContinuedFigure FigureFigure 2-15.GAS CONTROL VALVE REPLACEMENT Continuedpower switch to OFF and disconnect main circuit FigureFigure 2-16.BLOWER MOTOR REPLACEMENT ContinuedFigure Figure2-17 units will have power2-16 BLOWER MOTOROhms cold Wire NosVoltage WattageCONTACTORS Checkout Power RemovedHeat Contactorunits will have power. Mercury 2-18.HEATINGFigure 2-18.HEATING CONTACTORS ELECTRIC ContinuedHeat Contactor ReplacementFigure Figure Replacement Primary Contactor2-18.HEATING CONTACTORS ELECTRIC Continued Figurebreaker, or unplug cord at wall receptacle 2-19.SPEAKER ASSEMBLYpower switch to OFF and disconnect main circuit Figurebreaker, or unplug cord at wall receptacle power switch to OFF and disconnect main circuitFigure Checkout1. Drain the shortening from the frypot 2-20.HIGH TEMPERATUREconnect the two electrical wires LIMIT CONTROL ELECTRIC ContinuedFigure terminals2-20.HIGH TEMPERATURE LIMIT CONTROL ELECTRIC ContinuedFigure MOTOR REMOVALFigure Figureif applicable 2-21.FILTER PUMP AND MOTOR REMOVAL Continued2-22.AUTOLIFT TRANSFORMERpower switch to OFF and disconnect main circuit 2-24.AUTOLIFTACTUATOR MOTOR REPLACEMENTFigure 2-24.AUTOLIFT ACTUATOR MOTOR REPLACEMENTif applicable FigureFigure 10. Install new actuator in reverse order2-24.AUTOLIFT ACTUATOR MOTOR REPLACEMENT if applicableDrain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-31 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-32 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-33 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-34 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-35 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-36 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-37 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-38 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-39 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-40 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-41 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-42 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-43 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-44 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-45 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-46 3-1.INTRODUCTION 3-3.WHEN ORDERING3.6 WARRANTY SECTION 3. PARTS INFORMATIONQty. per Well Item NoPart No DescriptionDescription Gas ComponentsItem No Part NoDescription Gas Burner AssemblyItem No Part NoDescription Electric ComponentsItem No Part NoQty. per Well Item NoPart No DescriptionModel OFE/OFG/OEA/OGA-341,342 Description Qty. per UnitItem No Part NoQty. per Unit Item NoPart No DescriptionQty. per Unit Item NoPart No DescriptionQty. per Well Item NoPart No Description33501 Item NoDescription Qty. per UnitQty. per Well Item NoPart No DescriptionQty. per Well Item NoPart No DescriptionQty. per Well Item NoPart No DescriptionDescription Electric ComponentsItem No Part NoDescription OFG/OGA-341OFG/OGA-342 Item NoQty. per Well Item NoPart No DescriptionOFG/OFE ELECTRO MECHANICAL PARTS LIST PART NUMBERDESCRIPTION Description Item NoItem No Description71899 Description 341 DIRECT-CONNECTPARTS LIST Before March 1,342 DIRECT-CONNECTPARTS LIST Before March 1, Part NoItem No Part NoDescription Description Part NoDescription Part NoDescription 3-26 Part NoDescription Model OFE/OFG/OEA/OGA-341,342