Henny Penny High Volume Open Fryer
TECHNICAL MANUAL
Model OFE/OFG-341 Model OFE/OFG-342
Model OEA/OGA-341 Model OEA/OGA-342
Model OFE/OFG/OEA/OGA-341,342
FM06-030 Revised
Page
TABLE OF CONTENTS
Section
SECTION 1. TROUBLESHOOTING
1-2.SAFETY
1-1.INTRODUCTION
injury
1-3.TROUBLESHOOTING
PROBLEM
injuries and/or property damage could result
CAUSE
1-3.TROUBLESHOOTINGContinued
cleaning the fryer
thoroughly
PROBLEM
1-2.TROUBLESHOOTING
Continued
PROBLEM
CAUSE
1-4.ERROR CODES
DISPLAY
PANEL BOARD CORRECTION
CAUSE
1-4.ERROR CODES
Continued
DISPLAY
CAUSE
SECTION 2. MAINTENANCE
MAINTENANCE HINTS
HIGH TEMPERATURE
INTRODUCTION
Gas Units Continued
and remove the high limit from bracket
Figure
Figure
2-3.HIGH TEMPERATURE
Replacement
power switch to OFF and disconnect main circuit
power terminals
PANEL REPLACEMENT
2-5.POWER SWITCH
2-4.COMPLETE CONTROL
power switch to OFF and disconnect main circuit
2-5.POWER SWITCH Continued
Figure
Figure
Figure
1.Remove electrical power supplied to the fryer
Continued
Figure
Figure
2-8.FLAME SENSOR/ PILOT / IGNITOR ASSEMBLY GAS
Figure
Figure
Figure
Figure
power switch to OFF and disconnect main circuit
breaker, or unplug cord at wall receptacle
Figure
Figure
REPLACEMENT
1. Remove electrical power supplied to the unit
2-10.TRANSFORMER
those components with low voltage
power switch to OFF and disconnect main circuit
Figure
breaker, or unplug cord at wall receptacle
Figure
2-14.FILTER SWITCH
REPLACEMENT
1. Remove electrical power supplied to the unit
Figure
PROCEDURE, MOVE THE MAIN POWER SWITCH
BOX OR UNPLUG SERVICE CORD FROM WALL
TO AVOID PERSONAL INJURY OR PROPERTY
DAMAGE, BEFORE STARTING THIS
2-15.GAS CONTROL VALVE REPLACEMENT Continued
Figure
Figure
Figure
2-15.GAS CONTROL VALVE REPLACEMENT Continued
power switch to OFF and disconnect main circuit
Figure
Figure
2-16.BLOWER MOTOR REPLACEMENT Continued
Figure
Figure
Figure
units will have power
2-16
BLOWER MOTOR
2-17
Wire Nos
Voltage
Wattage
Ohms cold
Checkout Power Removed
Heat Contactorunits will have power. Mercury
2-18.HEATING
CONTACTORS
2-18.HEATING CONTACTORS ELECTRIC Continued
Heat Contactor
Replacement
Figure
Figure Replacement Primary Contactor
2-18.HEATING CONTACTORS ELECTRIC Continued
Figure
Figure
2-19.SPEAKER ASSEMBLY
power switch to OFF and disconnect main circuit
Figure
breaker, or unplug cord at wall receptacle
power switch to OFF and disconnect main circuit
Figure
Checkout
breaker, or unplug cord at wall receptacle
2-20.HIGH TEMPERATURE
connect the two electrical wires
LIMIT CONTROL ELECTRIC Continued
1. Drain the shortening from the frypot
terminals
2-20.HIGH TEMPERATURE
LIMIT CONTROL ELECTRIC Continued
Figure
MOTOR REMOVAL
Figure
Figure
Figure
2-21.FILTER PUMP AND MOTOR REMOVAL Continued
2-22.AUTOLIFT
TRANSFORMER
if applicable
2-24.AUTOLIFT
ACTUATOR MOTOR
REPLACEMENT
power switch to OFF and disconnect main circuit
2-24.AUTOLIFT ACTUATOR MOTOR REPLACEMENT
if applicable
Figure
Figure
10. Install new actuator in reverse order
2-24.AUTOLIFT ACTUATOR MOTOR REPLACEMENT
if applicable
Figure
2-31
Drain switch wired N/C
Model OFE/OFG/OEA/OGA-341,342
2-32
Drain switch wired N/C
Model OFE/OFG/OEA/OGA-341,342
2-33
Drain switch wired N/C
Model OFE/OFG/OEA/OGA-341,342
2-34
Drain switch wired N/C
Model OFE/OFG/OEA/OGA-341,342
2-35
Drain switch wired N/C
Model OFE/OFG/OEA/OGA-341,342
2-36
Drain switch wired N/C
Model OFE/OFG/OEA/OGA-341,342
2-37
Drain switch wired N/C
Model OFE/OFG/OEA/OGA-341,342
2-38
Drain switch wired N/C
Model OFE/OFG/OEA/OGA-341,342
2-39
Drain switch wired N/O
Model OFE/OFG/OEA/OGA-341,342
2-40
Drain switch wired N/O
Model OFE/OFG/OEA/OGA-341,342
2-41
Drain switch wired N/O
Model OFE/OFG/OEA/OGA-341,342
2-42
Drain switch wired N/O
Model OFE/OFG/OEA/OGA-341,342
2-43
Drain switch wired N/O
Model OFE/OFG/OEA/OGA-341,342
2-44
Drain switch wired N/O
Model OFE/OFG/OEA/OGA-341,342
2-45
Drain switch wired N/O
Model OFE/OFG/OEA/OGA-341,342
2-46
Drain switch wired N/O
Model OFE/OFG/OEA/OGA-341,342
3-3.WHEN ORDERING
3.6 WARRANTY
SECTION 3. PARTS INFORMATION
3-1.INTRODUCTION
Item No
Part No
Description
Qty. per Well
Gas Components
Item No
Part No
Description
Gas Burner Assembly
Item No
Part No
Description
Electric Components
Item No
Part No
Description
Item No
Part No
Description
Qty. per Well
Model OFE/OFG/OEA/OGA-341,342
Qty. per Unit
Item No
Part No
Description
Item No
Part No
Description
Qty. per Unit
Item No
Part No
Description
Qty. per Unit
Item No
Part No
Description
Qty. per Well
Item No
Description
Qty. per Unit
33501
Item No
Part No
Description
Qty. per Well
Item No
Part No
Description
Qty. per Well
Item No
Part No
Description
Qty. per Well
Electric Components
Item No
Part No
Description
OFG/OGA-341
OFG/OGA-342
Item No
Description
Item No
Part No
Description
Qty. per Well
DESCRIPTION
OFG/OFE ELECTRO MECHANICAL PARTS LIST
PART NUMBER
Item No
Description
71899
Item No
Description
341 DIRECT-CONNECTPARTS LIST Before March 1,
342 DIRECT-CONNECTPARTS LIST Before March 1,
Part No
Description
Description
Item No
Part No
Part No
Description
Part No
Description
Description
Part No
Description
Model OFE/OFG/OEA/OGA-341,342
3-26