Manuals / Henny Penny / Kitchen Appliance / Fryer

Henny Penny OFE/OFG-341, OFE/OFG-342, OEA/OGA-342, OEA/OGA-341 Item No, Description, 71899

Models: OEA/OGA-341 OEA/OGA-342 OFE/OFG-341 OFE/OFG-342

1 82

Page 77

Model OFE/OFG/OEA/OGA-341, 342

	OVER-THE-TOP FAUCET ASSY. (March 1, 2006 & After)
Item No.	Part No.	Description	Qty.
1	71899	ASSY. – 341 FAUCET	1
	17333	FEMALE DISCONNECT	1
1	71665	ASSY. – 342 FAUCET	1
	17334	MALE DISCONNECT	1
2	71830	HANDLE – DIVERTER VALVE (Direct-Connect units)	1

1209

3-21

Page 77

Image 77

Henny Penny OFE/OFG-341, OFE/OFG-342, OEA/OGA-342, OEA/OGA-341 technical manual Item No, Description, 71899

Contents

TECHNICAL MANUAL Henny Penny High Volume Open FryerModel OFE/OFG-341 Model OFE/OFG-342 Model OEA/OGA-341 Model OEA/OGA-342Model OFE/OFG/OEA/OGA-341,342 FM06-030 Revised Page TABLE OF CONTENTSSection 1-2.SAFETY SECTION 1. TROUBLESHOOTING1-1.INTRODUCTION injuryPROBLEM 1-3.TROUBLESHOOTINGinjuries and/or property damage could result CAUSEcleaning the fryer 1-3.TROUBLESHOOTINGContinuedthoroughly PROBLEMContinued 1-2.TROUBLESHOOTINGPROBLEM CAUSEDISPLAY 1-4.ERROR CODESPANEL BOARD CORRECTION CAUSEContinued 1-4.ERROR CODESDISPLAY CAUSEMAINTENANCE HINTS SECTION 2. MAINTENANCEHIGH TEMPERATURE INTRODUCTIONand remove the high limit from bracket Gas Units ContinuedFigure FigureReplacement 2-3.HIGH TEMPERATUREpower switch to OFF and disconnect main circuit power terminals2-5.POWER SWITCH PANEL REPLACEMENT2-4.COMPLETE CONTROL power switch to OFF and disconnect main circuitFigure 2-5.POWER SWITCH ContinuedFigure FigureContinued 1.Remove electrical power supplied to the fryerFigure Figure2-8.FLAME SENSOR/ PILOT / IGNITOR ASSEMBLY GAS Figure FigureFigure Figurebreaker, or unplug cord at wall receptacle power switch to OFF and disconnect main circuitFigure Figure1. Remove electrical power supplied to the unit REPLACEMENT2-10.TRANSFORMER those components with low voltageFigure power switch to OFF and disconnect main circuitbreaker, or unplug cord at wall receptacle FigureREPLACEMENT 2-14.FILTER SWITCH1. Remove electrical power supplied to the unit FigureBOX OR UNPLUG SERVICE CORD FROM WALL PROCEDURE, MOVE THE MAIN POWER SWITCHTO AVOID PERSONAL INJURY OR PROPERTY DAMAGE, BEFORE STARTING THISFigure 2-15.GAS CONTROL VALVE REPLACEMENT ContinuedFigure Figurepower switch to OFF and disconnect main circuit 2-15.GAS CONTROL VALVE REPLACEMENT ContinuedFigure FigureFigure 2-16.BLOWER MOTOR REPLACEMENT ContinuedFigure Figure2-16 units will have powerBLOWER MOTOR 2-17Voltage Wire NosWattage Ohms coldHeat Contactorunits will have power. Mercury Checkout Power Removed2-18.HEATING CONTACTORSHeat Contactor 2-18.HEATING CONTACTORS ELECTRIC ContinuedReplacement Figure2-18.HEATING CONTACTORS ELECTRIC Continued Figure Replacement Primary ContactorFigure Figurepower switch to OFF and disconnect main circuit 2-19.SPEAKER ASSEMBLYFigure breaker, or unplug cord at wall receptacleFigure power switch to OFF and disconnect main circuitCheckout breaker, or unplug cord at wall receptacleconnect the two electrical wires 2-20.HIGH TEMPERATURELIMIT CONTROL ELECTRIC Continued 1. Drain the shortening from the frypot2-20.HIGH TEMPERATURE terminalsLIMIT CONTROL ELECTRIC Continued FigureFigure MOTOR REMOVALFigure Figure2-22.AUTOLIFT 2-21.FILTER PUMP AND MOTOR REMOVAL ContinuedTRANSFORMER if applicableACTUATOR MOTOR 2-24.AUTOLIFTREPLACEMENT power switch to OFF and disconnect main circuitif applicable 2-24.AUTOLIFT ACTUATOR MOTOR REPLACEMENTFigure Figure2-24.AUTOLIFT ACTUATOR MOTOR REPLACEMENT 10. Install new actuator in reverse orderif applicable Figure2-31 Drain switch wired N/CModel OFE/OFG/OEA/OGA-341,342 2-32 Drain switch wired N/CModel OFE/OFG/OEA/OGA-341,342 2-33 Drain switch wired N/CModel OFE/OFG/OEA/OGA-341,342 2-34 Drain switch wired N/CModel OFE/OFG/OEA/OGA-341,342 2-35 Drain switch wired N/CModel OFE/OFG/OEA/OGA-341,342 2-36 Drain switch wired N/CModel OFE/OFG/OEA/OGA-341,342 2-37 Drain switch wired N/CModel OFE/OFG/OEA/OGA-341,342 2-38 Drain switch wired N/CModel OFE/OFG/OEA/OGA-341,342 2-39 Drain switch wired N/OModel OFE/OFG/OEA/OGA-341,342 2-40 Drain switch wired N/OModel OFE/OFG/OEA/OGA-341,342 2-41 Drain switch wired N/OModel OFE/OFG/OEA/OGA-341,342 2-42 Drain switch wired N/OModel OFE/OFG/OEA/OGA-341,342 2-43 Drain switch wired N/OModel OFE/OFG/OEA/OGA-341,342 2-44 Drain switch wired N/OModel OFE/OFG/OEA/OGA-341,342 2-45 Drain switch wired N/OModel OFE/OFG/OEA/OGA-341,342 2-46 Drain switch wired N/OModel OFE/OFG/OEA/OGA-341,342 3.6 WARRANTY 3-3.WHEN ORDERINGSECTION 3. PARTS INFORMATION 3-1.INTRODUCTIONPart No Item NoDescription Qty. per WellItem No Gas ComponentsPart No DescriptionItem No Gas Burner AssemblyPart No DescriptionItem No Electric ComponentsPart No DescriptionPart No Item NoDescription Qty. per WellModel OFE/OFG/OEA/OGA-341,342 Item No Qty. per UnitPart No DescriptionPart No Item NoDescription Qty. per UnitPart No Item NoDescription Qty. per UnitPart No Item NoDescription Qty. per WellDescription Item NoQty. per Unit 33501Part No Item NoDescription Qty. per WellPart No Item NoDescription Qty. per WellPart No Item NoDescription Qty. per WellItem No Electric ComponentsPart No DescriptionOFG/OGA-342 OFG/OGA-341Item No DescriptionPart No Item NoDescription Qty. per WellDESCRIPTION OFG/OFE ELECTRO MECHANICAL PARTS LISTPART NUMBER Description Item No71899 Item NoDescription 342 DIRECT-CONNECTPARTS LIST Before March 1, 341 DIRECT-CONNECTPARTS LIST Before March 1,Part No DescriptionDescription Item NoPart No Description Part NoPart No DescriptionDescription Description Part NoModel OFE/OFG/OEA/OGA-341,342 3-26