PRODUCT SPECIFICATIONS
Generator Specifications
Rated Surge Watts . . . . . . . . . . . . . . . 1,000 Watts Rated Running Watts . . . . . . . . . . . . . 900 Watts Rated Maximum Current
At 120 Volts AC . . . . . . . . . . . . . .7.5 Amps At 12 Volts DC . . . . . . . . . . . . . . .8.3 Amps Phase . . . . . . . . . . . . . . . . . . . . . . . .Single Phase
Rated Frequency . . . . . . . . . . . . . . . .60 Hertz Packaged Weight . . . . . . . . . . . . . . . .61 lbs.
Engine Specifications
Model . . . . . . . . . . . . . . . . . . . . . . . . Mitsubishi GM82 Rated Horsepower . . . . . . . . . . . . . . 2.4 at 4000 rpm Displacement . . . . . . . . . . . . . . . . . . . 80cc
Spark Plug Type: . . . . . . . . . . . . . . . . . NGK BP6HS or equivalent
Set Gap To: . . . . . . . . . . . . . . . . . . . . . 0.030inch (0.75mm) Fuel Capacity . . . . . . . . . . . . . . . . . . . 1.2 U.S. gallons (4.5 l)
GENERAL MAINTENANCE RECOMMENDATIONS
The generator warranty does not cover items that have been subjected to operator abuse or negligence. To receive full value from the warranty, operator must maintain generator as instructed in this manual.
Some adjustments will need to be made periodically to properly maintain your generator.
All adjustments in this section should be made at least once each season. Follow the requirements in the “Maintenance Schedule” chart shown below in Figure 11.
NOTE: Once a year you should clean or replace the spark plug and replace the air filter. A new spark plug and clean air filter assure proper fuel-air mixture and help your engine run better and last longer.
GENERATOR
MAINTENANCE
Generator maintenance consists of keeping the unit clean and dry. Operate and store the unit in a clean dry environment where it will not be exposed to excessive dust, dirt, moisture or any corrosive vapors. Cooling air slots in the generator must not become clogged with snow, leaves or any other foreign material.
Figure 11 – Maintenance Schedule
Item | Operation | Each use | First Month or | Every 3 months | Every 6 months |
| | | 25 hours | or 50 hours | or 100 hours |
Engine oil | Check level | X | | | |
| Change | | X | X | |
Air cleaner | Check | X | | | |
| Clean | | | X (1) | |
Spark arrester | Check – Clean | | | X (2,3) | |
Spark plug | Check – Clean | | | X | |
Valve clearance | Check – Adjust | | | | X (3) |
Fuel tank strainer | Clean | | | | X (3) |
Fuel line | Check (Replace if | | Every 3 years (3) | | |
| necessary) | | | | |
1 Clean more often under dirty or dusty conditions. Replace cleaner parts if very dirty.
2 Check every 10 hours or 3 months.
3 These items should be serviced by an authorized dealer, unless the owner has the proper tools and is mechanically proficient.
1000 Starting Watts
Equipment Description
Table of Contents
Safety Rules
When Storing Fuel or Equipment with Fuel in Tank
When Adding Fuel
When Operating Equipment
When Transporting or Repairing Equipment
Use generator only for intended uses
When Adjusting or Making Repairs to Your Generator
Know Your Generator
Engine ON/OFF Switch Used to stop a running engine
Add Fuel
Assembly
Carton Contents
Before Starting Engine
Starting the Engine
Grounding Generator
Operating Generator
Stopping the Engine
Connecting Electrical Loads
Charging a Battery
Oil Alert System
Volt AC, 15 Amp Receptacle
Connector Plugs
Volt DC Accessory Jack
Extension Cords
Example
Power Management
Dont Overload Your Generator
Capacity
Generator Specifications
Product Specifications
General Maintenance Recommendations
Generator Maintenance
Checking Oil Level
Engine Maintenance
To Clean the Generator
Clean/Replace Spark Plug
Storage Instructions
Service Air Cleaner
Clean Spark Arrester Screen
To clean or replace air filter element
Other Storage Tips
Long Term Storage Instructions
900W Generator
Problem Cause Correction
Troubleshooting
Wiring Diagram
HHCS, FLNG, M8-1.25 X
Exploded View and Parts List Main Unit
Qty Description
CAP, Fuel
Cylinder Block, Cylinder Head Qty Description
Exploded View and Parts List Engine
Crankcase Cover, Crankshaft/Camshaft Qty Description
SET, RING, PSTN, STD
Piston/Rod, Magneto/Flywheel, Air Cleaner Qty Description
Carburetor, Control/Linkages Qty Description
Fan Cover, Recoil Starter, Oil Sensor Qty Description
Lead Wires, Muffler, Gasket Set Qty Description
Emission Control System Warranty
2nd year parts only Year
About your equipment warranty
Equipment Consumer Use Commercial Use
Year
Avertissement
Table DES Matières
Description DE L Équipement
Règles DE Sécurité
Lorsque Vous Transportez OU Réparez Léquipement
Lorsque Vous Ajoutez DU Carburant
Lorsque Léquipement Fonctionne
Lorsque Vous Réglez OU Réparez Votre Générateur
Lanceur Dispositif utilisé pour le démarrage du moteur
Connaissez Votre Générateur
Ajouter de lhuile
Assemblage
Avant LE Démarrage DU Moteur
Les Contenus De Boîte
Démarrage du Moteur
Mise À LA Terre DU Générateur
Utilisation DU Générateur
Système dalerte de niveau dhuile
Recharge dune Batterie
Branchement des Charges Électriques
Arrêt du Moteur
Prise de 120 volts CA, 15 ampères
Fiches DE Connexion
Rallonges
Prise auxiliaire de 12 volts CC
Exemple
NE Surchargez PAS Votre Générateur
Capacité
Gestion de la Consommation
Caractéristiques du moteur
Recommandations Générales Dentretien
Entretien DU Générateur
Caractéristiques Caractéristiques de la génératrice
Vérification du niveau dhuile
Nettoyage/Remplacement de la bougie dallumage
Entretien DU Moteur
Pour Nettoyer le Générateur
Transport et entreposage
Directives Dentreposage
Entretien du filtre à air
Nettoyage de lécran pare-étincelles
Vous DE Vider LE Réservoir Dessence
Directives dentreposage à long terme
Autres conseils dentreposage
Dépannage
Responsabilités de la garantie du propriétaire
Garantie DU Dispositif Antipollution
Équipement Usage par un consommateur
En vigueur à partir du 1er Janvier
Garantie Limitée
Période DE Garantie
Advertencia
Tabla DE Contenidos
Descripción DEL Equipo
Instrucciones DE Seguridad
Cuando Transporte O Repare EL Equipo
Peligro
Cuando Añada Combustible
Cuando Opere EL Equipo
Cuando Ajuste O Haga Reparaciones a SU Generador
Precaución
Interruptor de Encendido APAGADO/ENCENDIDO
Conozca SU Generador
Añadir Aceite de Motor
Montaje
Antes DE Darle Arranque AL Generador
Contenido del Empaque
Para Arrancar el Motor
Conexion a Tierra DEL Generador
Cómo Utilizar SU Generador
Procedimiento de Carga de la Bateria
Conexion de Cargas Elecricas
Detener el Motor
Aceite Sistema Alerta
Receptáculo de 120 Voltios AC
Enchufes DE Conexión
Cables DE Extensión
Clavija Accesoria de 12 Voltios DC, 8.3 Amperios
Ejemplo
No Sobrecargue EL Generador
Capacidad
Control de la Energía
Especificaciones del Generador
Especificaciones DEL Producto
Recomendaciones Mantenimiento Generales
Mantenimiento DEL Generador
Cambiar el Aceite del Motor
Mantenimiento DEL Motor
Para Limpiar el Generador
Verfique el Nivel de Aceite
Transporte y Almacenamiento
Instrucciones DEL Almacenamiento
Mantenimiento del Filtro de Aire
Limpieza del Filtro del Amortiguador de Chispas
Asegúrese DE Vaciar EL Tanque DE Combustible
Instrucciones de Almacenamiento a Largo Plazo
Otros Consejos de Almacenamiento
Notas
Diagnóstico Y Reparación DE Averías
Responsabilidades del propietario para la garantía
Garantia DEL Sistema DE Control DE Emisiones
Acerca de la seguridad de su equipo
Efectiva desde el 1ro de Enero
Garantía Limitada
Equipo Para Uso Del Consumidor Para Uso Comercial