Briggs & Stratton 074000 Cleaning Unit, Inspect / Clean Air Filter, General Maintenance

Page 13

5.Use an adjustable wrench to remove hex head drain plug.

6.Fully drain oil into container. Install drain plug and tighten using adjustable wrench. Dispose of used oil properly.

7.Using oil funnel, slowly add recommended oil. Check oil level frequently with dipstick to avoid overfilling Compressor Pump (see Figure 8).

8.When oil is at proper level, reinstall oil dipstick and wipe up any spilled oil.

Cleaning Unit

To prolong compressor life, perform these steps weekly. If the operating environment is particularly dirty, perform daily.

1.Push ON - OFF switch to OFF and unplug unit.

WARNING

Operating air compressor and tubing are HOT and can cause burns.

•DO NOT touch compressor or tubing.

•Allow compressor to cool before servicing.

2.Use a soft cloth and a small brush for cleaning accumulated dirt and debris from the following locations:

•Louvers on left end of motor shroud (on opposite end from Oil Fill Location, see Figure 9)

Figure 9 - Cooling Fins
	Shroud Louvers
	Cooling Fins
•	Cooling fins on top of Air Compressor Pump

MAINTENANCE

•Cooling fins on sides of Air Compressor Pump, especially between sides of pump and shroud

•Oil fill and adjacent area on air pump housing

•Oil drain on air pump housing

•Pressure Control knob, gauges, quick connect fitting, and Safety Valve

General Maintenance

Keep your air compressor clean and dry by placing it in a location far away from sources of contamination. Make sure the unit is kept in a well-ventilated area. Protect hoses, connectors, quick connects, and accessories from damage.

IMPORTANT: DO NOT use jets of water or flammable liquids to clean unit.

Inspect / Clean Air Filter

Use the following steps to check and clean the compressor’s internal air filter.

1.With air tank fully pressurized (ON - OFF switch in ON position and motor stopped), push ON - OFF switch to OFF position. Disconnect power cord from outlet.

2.Use phillips screwdriver to remove screw holding air filter cover and remove air filter cover (see Figure 10).

Figure 10 - Servicing Air Filter

Air Filter Media

Compressor

Filter Housing

3.Remove air filter media.

IMPORTANT: DO NOT operate compressor with air filter media removed.

13

Image 13

Contents Call Helpline Appelez Ligne dassistance Llame Línea Directa Operator’s Manual Manuel d’utilisation Manual del OperarioSafety Rules Table of ContentsEquipment Description Make this manual available to other users of this equipment Safety RulesStay Clear Compressor can start any time when pluggedCarton Contents AssemblyUnpacking Features and Controls Features and ControlsQuick Connect Fitting Connect air tools here Operation Break-In ProcedureAdd Oil OperationGrounding Instructions Air Compressor Operating LocationStarting Your Air Compressor Pressure Control KnobExtension Cords Stopping Your Air CompressorCompressor Operation Overload Protection ResetMaintenance Product SpecificationsSpecifications / Maintenance Maintenance Service Dates Schedule Service IntervalsMaintenance Inspect Safety ValveInspect Quick Connect Fitting and Tank Drain Valve Inspect / Change Pump OilInspect / Clean Air Filter Cleaning UnitGeneral Maintenance Inspect Pump Intake and Exhaust Valves Inspect Safety LabelsStorage StorageTroubleshooting TroubleshootingBefore You Call Compressor is not Supplying enough air to Operate accessoriesMotor will not run Glossary GlossaryLimited Warranty Description DE L Équipement Table DES MatièresRègles DE Sécurité Description / Règles DE SécuritéRègles DE Sécurité AvertissementÉLOIGNEZ-VOUS Mise EN GardeAssemblage AssemblageContenu de la boîte DéballageFonctions ET Commandes Fonctions ET CommandesSoupape de relâchement de surpression non illustrée Ajoutez de l’huile OpérationProcédure de rodage OpérationDirectives de mise à la terre Emplacement du compresseur d’air lors de l’utilisationDémarrage de votre compresseur d’air ’UTILISEZ PAS UN Adaptateur DE Mise À LA TerreRallonges Arrêt de votre compresseur d’airFermez le robinet de vidange Remarque Évitez d’utiliser des rallongesRéarmement du protecteur de surcharge Utilisation du compresseurBouton de RéarmementEntretien SpécificationsSpécifications / Entretien Fréquence C.A HzVérifiez la soupape de sûreté EntretienVérifiez/changez l’huile de la pompe Vérification du niveau d’huileVérifiez/nettoyez le filtre à air Nettoyage de l’unitéEntretien général Entretien / Entreposage EntreposageVérifiez les étiquettes de sécurité Remarque Remplacez le filtre s’il est extrêmement saleAvant de nous contacter DépannageDépannage Suffisamment d’air pour le Le compresseur ne fournit pasLe moteur ne fonctionne pas Glossaire GlossaireRemarques RemarquesPériode DE Garantie Descripción DEL Equipo Tabla DE ContenidosReglas DE Seguridad Descripción Y Reglas DE SeguridadReglas DE Seguridad AdvertenciaManténgase Alejado PrecauciónMontaje MontajeContenido de la caja DesembalajeCaracterísticas Y Mandos Características Y MandosAcoplamiento para conector rápido Permiten conectar Bomba del compresor de aire La bomba comprime el aire enAñadir aceite OperaciónProcedimiento de preparación para el uso inicial OperaciónInstrucciones de conexión a tierra Colocación del compresorPuesta en marcha del compresor de aire No Utilice UN Adaptador DE Conexión a TierraCables prolongadores Parada del compresor de aireNota No utilice cables prolongadores Uso del compresor Botón ResetRearme de la protección contra sobrecarga Mantenimiento EspecificacionesEspecificaciones / Mantenimiento Inspeccione la válvula de seguridad MantenimientoInspeccione / cambie el aceite de la bomba Comprobación del nivel de aceiteInspeccione / limpie el filtro de aire Limpieza de la unidadMantenimiento general Inspeccione las etiquetas de seguridad Inspeccione las válvulas de admisión y escape de la bombaNota Sustituya el elemento filtrante si está muy sucio Almacenamiento AlmacenamientoDiagnositicos DE Averías Diagnositicos DE AveríasAntes de llamar Suficiente para accionar los El compresor no suministra aireAccesorios El motor no funcionaGlosario GlosarioNotas NotasPeríodo DE Garantía