Wayne-Dalton 9800 Series installation instructions Cleaning Your Steel And Fiberglass Garage Door

Page 38

Cleaning Your Steel And Fiberglass Garage Door

IMPORTANT: DO NOT USE A PRESSURE WASHER ON GARAGE DOOR!

While factory-applied finishes on garage doors are durable, it is desirable to clean them on a routine basis. Some discoloration of the finish may occur when a door has been exposed to dirt-laden atmosphere for a period of time. Slight chalking may also occur as a result of direct exposure to sunlight.

Cleaning the door will generally restore the appearance of the finish. To maintain an aesthetically pleasing finish of the garage door, a periodic washing of the garage door is recommended.

The following cleaning solution is recommended:

A mild detergent solution consisting of one cup detergent (with less than 0.5% phosphate) dissolved into five gallons of warm water will aid in the removal of most dirt.

NOTES: The use of detergents containing greater than 0.5% phosphate is not recommended for use in general cleaning of garage doors.

NOTES: Be sure to clean behind weather stripping on both sides and top of door.

CAUTION: NEVER MIX CLEANSERS OR DETERGENTS WITH BLEACH.

GLASS CLEANING INSTRUCTIONS

Clean with a mild detergent solution (same as above) and a soft cloth. After cleaning, rinse thoroughly.

ACRYLIC CLEANING INSTRUCTIONS

Clean acrylic glazing with nonabrasive soap or detergent and plenty of water. Use your bare hands to feel and dislodge any caked on particles. A soft, grit-free cloth, sponge or chamois may be used to wipe the surface. Do not use hard or rough cloths that will scratch the acrylic glazing. Dry glazing with a clean damp chamois.

NOTE: DO NOT USE any window cleaning fluids, scouring compounds, gritty cloths or solvent-based cleaners of any kind.

38Please Do Not Return This Product To The Store. Contact your local Wayne-Dalton dealer. To find your local Wayne-Dalton dealer, refer to your local

yellow pages business listings or go to the Find a Dealer section online at www.Wayne-Dalton.com

Image 38

Contents Series 4 Section Important NoticeTable of Contents Package Contents PRE-INSTALLATIONDoor Section Identification 3/16 Drill Bits Power DrillTools Required GlovesWinding bars can cause spring Energy to be released Torsion Spring Removal For Standard LiftFailure to use approved Suddenly, resulting in severe Or fatal injuryUnwind Springs Bracket and Drive Gear TorqueMaster SpringRemoval Extension Spring Removal Removing the Old DoorPreparing the Opening Tools Needed None InstallationAttaching Quick Install Flag Angle to Vertical Track FlagangleTap the horizontal angle towards Be installed as shownHorizontal Angle AsideBrackets Installing Q.I. Jamb Brackets Bottom Section Vertical TrackStacking Sections Endcap Top BracketsWith the second set of holes from 20 x 5/8 carriage boltsOperator Bracket Top Section Injury Attaching Horizontal Track toDo not Raise Door Until This step Hex nutsAdjusting Top Brackets Center Bracket Bushing Must install the center bracket bushingTorqueMaster Spring Tube Continue with Step Idrive opener on your garage door, youIdrive Installation Cable Drum Installation Tools Needed Lubricating Oil Drive Gear InstallationEnd Brackets Repeat for left hand side.`Installations on page 35, Figure B Counter InstallationSecuring Center Bracket Assembly Repeat for left hand side for double spring applicationsPositioning Support Bracket Handle Bracket Attaching Disconnect CablesMounting Disconnect Bracket Disconnect handle. ThreadDisconnect handle Secure disconnect cable toTools Needed Locking Pliers Flat Tip Screwdriver Cable AdjustmentsTools Needed Vice Clamp Important do not USE Impact GUN to Wind SpringsRecommended Spring Turns Setting Spring TensionWinding Bolt Rotation Keep horizontal track Drum Wrap InstallationRear Support Parallel and within 3/4 Maximum of door edgeTools Needed Adjust weather seal or door stop ifAttach horizontal tracks to the rear Weather seal or door stop to both doorSide Lock DoorMaster TM BracketNo Scew EYE Pull Rope Bottom Bracket Tools Needed Power Drill Drill BitPull Rope Result in Severe or Fatal Injury Trolley OperatorOperator Must be Tested AT Time Door is fully open trolley rail willAcrylic Cleaning Instructions Cleaning Your Steel And Fiberglass Garage DoorGlass Cleaning Instructions Important do not USE a Pressure Washer on Garage DoorSteel Preparation For Painting Fiberglass Refinishing And Or FinishingLifetime Limited Warranty Model Thank you for your purchase