Balcar R410A Concealed Duct type, 182, High-EfficiencyFilter, Safety Cautions, Specifications

Concealed Duct type

High-Efficiency Filter	Installation Manual
High-Efficiency filter (65%)	Model: TCB-UFM11BE
	TCB-UFM21BE
	TCB-UFM31BE
	TCB-UFM41BE
High-Efficiency filter (90%)	Model: TCB-UFH51BE
	TCB-UFH61BE
	TCB-UFH71BE
	TCB-UFH81BE

NOTES

•For installation of the filter, refer to the rear side of this manual.

•Keep this Manual with Owner’s Manual.

Installation of high-efficiency filter
1 Remove the air filter, and install high-efficiency filter to the
suction port.		High-efficiency
Push the high-efficiency filter completely up to the end.		filter
Check that the rear side is hanged to the hook.
2 Install the air filter		Hook
Be sure to fix the air filter with clamps in order to prevent falling.	Indoor unit
(Clamps are attached to the indoor unit.)		High-efficiency
NOTE		filter
These filter cannot be reused even if it is washed.		Air filter

To install a filter sold separately, be sure to set the fan referring the following description.

* The filter sold separately cannot be installed to an air conditioner built in with auxiliary electric heater.

Setup of fan when building in the high-efficiency filter:

Necessary at initial installation only

Safety Cautions

•Before installation work, read thoroughly this “Safety Cautions” to install the air conditioner correctly.

•This “Safety Cautions” describes the important contents concerned to the safety. Be sure to keep in mind these items. Symbols and meanings are as described below.

WARNING	Indicates “User may be dead or seriously injured (*1) if it is incorrectly used.”
	Indicates “It is assumed that user may be injured (*2) or property damage (*3) may occur if it is

Two methods are provided for setup, one is to use a wired remote controller sold separately	SET DATA		CODE No.
and the other is to exchange the short plug on the indoor microcomputer P.C. board.		UNIT No.
	SETTING	R.C. No.

[Using a wired remote controller sold separately]		4			2
(Procedure) Perform the setup while the equipment stops.
		6
1 Push SET + CL +	buttons concurrently for 4 seconds or more.				3
		1		UNIT
The firstly displayed unit No. is the master indoor unit address of the group control.			SET CL
In this time, the fan of the selected indoor unit only operates.					5

– 182 –

CAUTION incorrectly used.”

*1: “Serious injury” means a disease which has an after-effect or requires hospitalization or long-term going to the hospital for treatment, such as loss of sight, burn (by high temperature or low temperature), electric shock, fracture, poisoning, etc.

*2: “Injury” means hurt, burn, electric shock, etc. which does not require hospitalization or long-term going to the hospital for treatment.

*3: “Property damage” means enlarged damage concerned to house, household effects, domestic animal, pet, etc.

Explanation of picture symbols

indicates prohibition (prohibited action).

2 Every pushing UNIT button, No. of the group control units are displayed in order.

In this time, the fan of the selected indoor unit only operates.

3 Using set temperature and buttons, specify the item code “5d”.

4 Using timer time and buttons, select from the set data.

For contents of the setup data, refer to the table at the right.

5	Push SET	button.
6	(When flashing display changes to lighting display, the setup completes.)
	Pushing	button returns the state to the normal stop state.

*Setup can be performed only by the wired remote controller. If setup is not performed, air volume is decreased and dewing occurs.

• Item code 5d

Set data	Filter sold separately
0000	Standard filter (At shipment)
	High-efficiency filter (65%)
0001	(TCB-UFM11BE to UFM41BE)
	High-efficiency filter (90%)
	(TCB-UFH51BE to UFH81BE)

The concrete prohibited action is indicated with picture or sentence in or near the picture symbol.

[Exchange of short plug on indoor microcomputer P.C. board]

indicates that the forced instructed action (Act necessarily).

The concrete instructed action is indicated with picture or sentence in or near the picture symbol.

indicates an item with care.

The concrete item to be cautioned is indicated with picture or sentence in or near the picture symbol.

WARNING	CAUTION
• Do not put a plastic bag including filter on a place where	• Install the suction grille surely to the main unit.

hands of a small child can reach.	If an incomplete installation is performed,
If the child puts the bag on his head, it may seal
	falling of the suction grille causes an injury.
his mouth or nose resulting in choke of death.

Specifications

High-efficiency filter	TCB-	TCB-	TCB-	TCB-	High-efficiency filter	TCB-	TCB-	TCB-	TCB-
(65%) model name	UFM11BE	UFM21BE	UFM31BE	UFM41BE	(90%) model name	UFH51BE	UFH61BE	UFH71BE	UFH81BE
Conformed air				1101BT	Conformed air				1101BT
	—	561BT	801BT	to		—	561BT	801BT	to
conditioner model name					conditioner model name
				1401BT					1401BT
Quantity	1	1	2	2	Quantity	1	1	2	2
Dust collecting effect		Color test 65%			Dust collecting effect		Color test 90%
Operation time		2500 hours			Operation time		1800 hours

To exchange the static pressure, there is a method other than the abovementioned method by wired remote controller, which is to shift the short plug on the indoor microcomputer P.C. board as shown in the following table. Adopt this method in case of using a wireless remote controller, etc.

*However, after exchanging once, be careful to shift the short plug to the standard position (At shipment) in order to return to the standard setup (follow to E2PROM setup) though the setup for high static-pressure 1, high static-pressure 2, or low static-pressure can be arbitrarily performed. It is necessary to rewrite data from the wired remote controller sold separately in the set data “0000”.

•Select with shifting of the short plug on the indoor unit microcomputer P.C. board.

Short plug position (CN112, CN111, CN110 from the left)

*1 Resistance of high- efficiency filter 65 and 90, deodorant filter, or ammonium filter is equivalent to 30Pa. Therefore, set the resistance (external static pressure) of a duct to be connected to 40Pa.

Short plug position
		External	Filter sold separately
		static
		pressure
	Short Open
CN112 CN111 CN110		40Pa	Standard filter
		Standard	(At shipment)
		(At shipment)	Zeolite-3G deodorant filter
CN112 CN111 CN110		70Pa	*1
		High static-	High-efficiency filter 65
			High-efficiency filter 90
		pressure 1
			Deodorant filter
			Ammonium filter
CN112 CN111 CN110		100Pa
		High static-	——
		pressure 2
CN112 CN111 CN110		20Pa
		Low static-	——
		pressure

TCB-UFH51,	TCB-UFM11,
61, 71, 81BE	21, 31,41BE

UFBE-E