Balcar R410A Concealed Duct type, 183, Deodorant Filter, Ammonium Filter, Safety Cautions, Notes

Concealed Duct type

Deodorant Filter, Ammonium Filter Installation Manual

Installation of filter sold separately
1 Remove the air filter, and install a filter sold separately to the		Filter sold
suction port.		separately
Push the filter sold separately completely up to the end.
Check that the rear side is hanged to the hook.
2 Install the air filter	Indoor unit	Hook
Be sure to fix the air filter with clamps in order to prevent falling.
		Filter sold separately
(Clamps are attached to the indoor unit.)
		• Deodorant filter

Deodorant Filter	Model: TCB-DF11BE
	TCB-DF21BE
	TCB-DF31BE

NOTES

NOTE	• Ammonium filter
	Air filter

These filter cannot be reused even if it is washed.

	TCB-DF41BE
Ammonium Filter	Model: TCB-DF11BE-AM
	TCB-DF21BE-AM
	TCB-DF31BE-AM
	TCB-DF41BE-AM

•Do not unpack the filter until you use it. (Otherwise, life of the deodorant filter or ammonium filter is shortened.)

•Keep this Manual with Owner’s Manual of the indoor unit.

Maintenance of filter sold separately

• Clean the filter sold separately once per 2 months.

1 Take out the filter sold separately in the reverse order of “Installation of filter sold separately”.

2 Sweep away the dust of the filter sold separately with a cleaner.

3

To install a filter sold separately, be sure to set the fan referring the following description.

*The filter sold separately cannot be installed to an air conditioner built in with auxiliary electric heater.

– 183 –

Safety Cautions

•Before installation work, read thoroughly this “Safety Cautions” to install the air conditioner correctly.

•This “Safety Cautions” describes the important contents concerned to the safety. Be sure to keep in mind these items. Symbols and meanings are as described below.

WARNING	Indicates “User may be dead or seriously injured (*1) if it is incorrectly used.”
CAUTION	Indicates “It is assumed that user may be injured (*2) or property damage (*3) may occur if it is
	incorrectly used.”

*1: “Serious injury” means a disease which has an after-effect or requires hospitalization or long-term going to the hospital for treatment, such as loss of sight, burn (by high temperature or low temperature), electric shock, fracture, poisoning, etc.

*2: “Injury” means hurt, burn, electric shock, etc. which does not require hospitalization or long-term going to the hospital for treatment.

*3: “Property damage” means enlarged damage concerned to house, household effects, domestic animal, pet, etc.

Explanation of picture symbols

indicates prohibition (prohibited action).

The concrete prohibited action is indicated with picture or sentence in or near the picture symbol.

indicates that the forced instructed action (Act necessarily).

The concrete instructed action is indicated with picture or sentence in or near the picture symbol.

indicates an item with care.

Install the filter sold separately.

Setup of fan when building in the filter sold separately:

Necessary at initial installation only

Two methods are provided for setup, one is to use a wired remote controller sold separately	SET DATA		CODE No.
and the other is to exchange the short plug on the indoor microcomputer P.C. board.		UNIT No.
	SETTING	R.C. No.

[Using a wired remote controller sold separately]		4			2
(Procedure) Perform the setup while the equipment stops.
1 Push SET + CL +	buttons concurrently for 4 seconds or more.	6		UNIT	3
The firstly displayed unit No. is the master indoor unit address of the group control.		1	SET CL
In this time, the fan of the selected indoor unit only operates.					5

2	Every pushing UNIT		button, No. of the group control units are displayed in			*	Setup can be performed only by the
							wired remote controller. If setup is not
	order.
							performed, air volume is decreased and
	In this time, the fan of the selected indoor unit only operates.
3							dewing occurs.
	Using set temperature			and	buttons, specify the item code “5d”.	•	Item code 5d
4	Using timer time		and	buttons, select from the set data.			Set data	Filter sold separately
	For contents of the setup data, refer to the table at the right.
5							0000	Standard filter (At shipment)
	Push SET	button.
								High-efficiency filter (65%)
	(When flashing display changes to lighting display, the setup completes.)
6							0001	(TCB-UFM11BE to UFM41BE)
	Pushing	button returns the state to the normal stop state.						High-efficiency filter (90%)
								(TCB-UFH51BE to UFH81BE)

[Exchange of short plug on indoor microcomputer P.C. board]

The concrete item to be cautioned is indicated with picture or sentence in or near the picture symbol.

WARNING	CAUTION
• Do not put a plastic bag including filter on a place where	• Install the suction grille surely to the main unit.

hands of a small child can reach.	If an incomplete installation is performed,
If the child puts the bag on his head, it may seal
	falling of the suction grille causes an injury.
his mouth or nose resulting in choke of death.

Specifications

Deodorant filter	TCB-	TCB-	TCB-	TCB-	Ammonium filter	TCB-	TCB-		TCB-	TCB-
model name	DF11BE	DF21BE	DF31BE	DF41BE	model name	UFH11BE-AM	UFH21BE-AM	UFH31BE-AM		UFH41BE-AM
Conformed air	—	561BT	801BT	1101BT	Conformed air	—	561BT		801BT	1101BT
conditioner model name				to	conditioner model name					to
				1401BT						1401BT
Quantity	1	1	2	2	Quantity	1	1		2	2
Initial deodorant		85%			Initial deodorant		95%
performance					performance
Deodorant durable		Approx. 9 months			Deodorant durable		Approx. 15 months
performance					performance

To exchange the static pressure, there is a method other than the abovementioned method by wired remote controller, which is to shift the short plug on the indoor microcomputer P.C. board as shown in the following table. Adopt this method in case of using a wireless remote controller, etc.

*However, after exchanging once, be careful to shift the short plug to the standard position (At shipment) in order to return to the standard setup (follow to E2PROM setup) though the setup for high static-pressure 1, high static-pressure 2, or low static-pressure can be arbitrarily performed. It is necessary to rewrite data from the wired remote controller sold separately in the set data “0000”.

•Select with shifting of the short plug on the indoor unit microcomputer P.C. board.

Short plug position (CN112, CN111, CN110 from the left)

*1 Resistance of high- efficiency filter 65 and 90, deodorant filter, or ammonium filter is equivalent to 30Pa. Therefore, set the resistance (external static pressure) of a duct to be connected to 40Pa.

Short plug position
		External	Filter sold separately
		static
		pressure
	Short Open
				TCB-DF11,	TCB-DF11,
CN112 CN111 CN110		40Pa	Standard filter
		Standard	(At shipment)
		(At shipment)	Zeolite-3G deodrant filter
		pressure 1	*1
CN112 CN111 CN110		70Pa
		High static-	High-efficiency filter 65
			High-efficiency filter 90
		100Pa	Deodorant filter	21,	21,
			Ammonium filter
CN112 CN111 CN110				31,	31,
		High static-	——
		pressure 2		41BE-AM	41BE
CN112 CN111 CN110		20Pa
		Low static-	——
		pressure

DEBF-E