Briggs & Stratton 074002 When Adjusting or Making Repairs to Your AIR Compressor

Page 5

WARNING

Unintentional sparking can result in fire or electric shock.

WHEN ADJUSTING OR MAKING REPAIRS TO YOUR AIR COMPRESSOR

•Disconnect the spark plug wire from the spark plug and place the wire where it cannot contact spark plug.

WHEN TESTING FOR ENGINE SPARK

•Use approved spark plug tester.

•DO NOT check for spark with spark plug removed.

CAUTION

Excessively high operating speeds increase risk of injury and damage to air compressor.

Excessively low speeds impose a heavy load.

•DO NOT tamper with governed speed.

•DO NOT modify air compressor in any way.

•DO NOT allow unqualified persons or children to operate or service air compressor.

CAUTION

Avoid prolonged or repeated skin contact with used engine oil.

•Used engine oil has been shown to cause skin cancer in certain laboratory animals.

•Thoroughly wash exposed areas with soap and water.

CAUTION

Serious damage may result if operating the unit with insufficient oil. Check oil level daily or with each use.

•Damage to equipment resulting from failure to follow this instruction will void warranty.

CAUTION

Serious damage may result if the break-in instructions are not closely followed.

•This procedure is required before the air compressor is put into service and when the Check Valve or a complete compressor pump has been replaced.

SAFETY RULES

WARNING

Fuel and its vapors are extremely flammable and explosive.

Fire or explosion can cause severe burns or death.

WHEN ADDING OR DRAINING FUEL

•Turn compressor engine OFF and let it cool at least 2 minutes before removing fuel cap. Loosen cap slowly to relieve pressure in tank.

•Fill or drain fuel tank outdoors.

•DO NOT overfill tank. Allow space for fuel expansion.

•If fuel spills, wait until it evaporates before starting engine.

•Keep fuel away from sparks, open flames, pilot lights, heat, and other ignition sources.

•DO NOT light a cigarette or smoke.

WHEN STARTING EQUIPMENT

•Ensure spark plug, muffler, fuel cap and air cleaner are in place.

•DO NOT start engine with spark plug removed.

WHEN OPERATING EQUIPMENT

•DO NOT spray flammable liquids, such as fuel or fuel oils.

•This air compressor is not for use in mobile equipment or marine applications.

•DO NOT tip air compressor at angle which causes fuel to spill.

•Secure air compressor in a stable position, especially when transporting.

•DO NOT stop engine by moving choke lever to CHOKE position.

WHEN TRANSPORTING OR REPAIRING EQUIPMENT

•Transport/repair with fuel tank EMPTY or with fuel shutoff valve OFF.

•Disconnect spark plug wire.

WHEN STORING FUEL OR EQUIPMENT WITH FUEL IN TANK

•Store away from furnaces, stoves, water heaters, clothes dryers or other appliances that have pilot light or other ignition source because they can ignite fuel vapors.

5

Page 4 Page 6
Image 5
Page 4 Page 6
Contents Call Helpline Appelez Ligne dassistance Llame Línea Directa 074002Equipment Description Table of ContentsSafety Rules Safety Rules Hazard Symbols and MeaningsSafety Rules When Testing for Engine Spark When Adjusting or Making Repairs to Your AIR CompressorWhen Adding or Draining Fuel When Starting EquipmentCarton Contents AssemblyUnpacking Verify Engine and Pump Oil LevelsFuel Level Indicator Install Pump Oil Breather CapDrain Valve shown in Open position Oil Fill LocationFeatures and Controls Features and ControlsCompressor Oil Fill Location Fill pump with oil here.Oil Quick Connect Fittings Connect air hoses hereOperation Break-In ProcedureAir Compressor Operating Location OperationStart valve is shown in Closed position Starting Your Air CompressorUse the handles to lift or carry the unit Stopping Your Air CompressorTransport Pressure Control Compressor OperationPower Ratings SpecificationsSpecifications Product SpecificationsMaintenance MaintenanceMaintenance Service Dates Service Intervals Maintenance TaskCleaning Unit MaintenanceGeneral Recommendations Emissions ControlInspect Quick Connect Fittings and Tank Drain Valves Inspect Safety ValveInspect Engine Oil Level Oil RecommendationsTo service the air cleaner, follow these steps Inspect Engine Air CleanerInspect Pump Oil Level Changing Engine OilOil Fill Opening Clean Spark Arrester ScreenCalling Changing Pump Oil Inspect / Clean Pump Air FilterFilter Housing Maintenance / Storage Inspect Safety LabelsStorage Inspect Spark PlugOther Storage Tips When Draining FuelStorage Change OilBefore You Call TroubleshootingTroubleshooting Lacks power starts Operate accessoriesCompressor is not Supplying enough air toGlossary GlossaryEmissions Owner’s Warranty Responsibilities Emissions Control System WarrantyLimited Warranty Warranty PeriodDescription DE L’ÉQUIPEMENT Table DES MatièresRègles DE Sécurité AvertissementRègles DE Sécurité Symboles de risque et leur significationChoc électrique Explosion Objets volants SurfaceAvertissement Lors DE Tests D’ALLUMAGE DU Moteur Mise EN GardeAssemblage AssemblageInstallez le bouchon reniflard de la pompe à lhuile Fonctions ET Commandes Fonctions ET CommandesFonctionnement Emplacement du compresseur d’air lors de l’utilisationFonctionnement Procédure de rodageTournez l’interrupteur ON/OFF du moteur à la position OFF Démarrage de votre compresseur d’airSuivez les directives de démarrage suivantes Le levier d’étrangleur est illustré à la position ChokeFermez les robinets de vidange Arrêt de votre compresseur d’airTransport Pression Utilisation du compresseurManomètre de pression Bouton de De sortie Caractéristiques SpécificationsPuissance nominale Caractéristiques du produitEntretien EntretienContrôle des émissions Recommandations généralesEntretien Nettoyage de l’unitéVérifiez la soupape de sûreté Recommandations relatives à l’huileVérifiez le niveau d’huile du moteur Vérification du niveau d’huile du moteurVérifiez le filtre à air du moteur Vérifiez le niveau d’huile de la pompeVidange de l’huile moteur Vérification du niveau d’huile de la pompeUtilisez un entonnoir et videz lentement de l’huile environ Nettoyage de l’écran pare-étincellesBouchon de vidange d’huile Orifice de Changement d’huile de la pompe Vérifiez/nettoyez le filtre à air de la pompeFiltre à air CompresseurEntretien / Entreposage EntreposageVérification de la bougie Vérifiez les étiquettes de sécuritéAutres conseils d’entreposage EntreposageChangement de l’huile Huilage de l’alésage du cylindreDépannage Problème Cause SolutionDépannage Avant de nous contacterLe compresseur ne fournit AccessoiresPas suffisamment d’air pour Le fonctionnement des Le moteur ne démarre pasGlossaire GlossaireÉmissions Garantie DU Dispositif Antipollution Garantie Limitée Période DE GarantieDescripción DEL Equipo Tabla DE ContenidoNormas DE Seguridad AdvertenciaSímbolos de peligro y sus significados Normas DE SeguridadAire ExplosiónAdvertencia Cuando Ajuste O Repare EL Compresor DE Aire PrecauciónMontaje MontajeTapón del respirador Instalación del tapón del respirador del aceite de la bombaDel aceite Punto de llenadoCaracterísticas Y Mandos Características Y MandosDel motor Estranguladora Filtro de aire Válvula delFuncionamiento FuncionamientoColocación del compresor de aire Procedimiento de preparación para el uso inicialAbierta Puesta en marcha del compresor de aireDespués de que el compresor de aire funcione durante Palanca en la posiciónTransporte Parada del compresor de aireMueva la palanca estranguladora hacia la posición FuncionamientoFigura 56 Control de presión Uso del compresorEspecificaciones EspecificacionesPotencia nominal Especificaciones del productoMantenimiento MantenimientoControl de emisiones Recomendaciones generalesMantenimiento Limpieza de la unidadInspeccione el nivel de aceite del motor Inspeccione la válvula de seguridadRecomendaciones sobre el aceite Inspección del nivel de aceite del motorInspeccione el filtro de aire del motor Inspeccione el nivel de la bomba de aceiteCambio del aceite del motor Inspección del nivel de la bomba de aceiteTapón de vaciado de aceite Limpieza de la pantalla apagachispasCambio del aceite de la bomba Inspeccione/limpie el filtro de aire de la bombaMANTENIMIENTO/ALMACENAMIENTO AlmacenamientoRevisión de la bujía Inspección de las etiquetas de seguridadOtras sugerencias para el almacenamiento AlmacenamientoCambio de aceite Aceite en el interior del cilindroResolución DE Problemas Resolución DE ProblemasProblema Motivo Corrección Antes de llamarOFF Glosario GlosarioNotas Emisiones Garantía DEL Sistema DE Control DE Emisiones Garantía Limitada Período DE Garantía
Top Page Image Contents