Manuals / Turbo Chef Technologies / Kitchen Appliance / Oven

Turbo Chef Technologies Residential Single and Double Wall Oven service manual

Models: Residential Single and Double Wall Oven

1 124

Download 124 pages 7.69 Kb

Troubleshooting Specifications Install Schematics Error Screens Wiring Harness Dimension Door Skin Replacement Accessing the Version Right Lock Motor Assembly

Page 23

Section 2

Oven Controls and Cooking -

The Speedcook Oven

Page 22 Page 24

Image 23

Turbo Chef Technologies Residential Single and Double Wall Oven Section Oven Controls and Cooking Speedcook Oven

Page 22 Page 24

Related pages Troubleshooting for JVC CA-MXJ950R Is installed for Harman-Kardon AVR 445

Contents

For the turbochef residential single and double wall ovens Page For further information, call 866.447.3783 TurboChef Technologies, Inc Table Of Contents Oven Controls and Cooking Lower Oven Double-Wall Oven Only Info Mode Oven Systems RTD Troubleshooting RTD Appendix Replacing Oven Components Schematics Safety Precautions Read ALL Instructions Before Using Grounding Instructions Power ConnectionsSelf-Cleaning Oven Guidelines Surfaces of Oven Iii RF Interference Considerations Iv Saftey Instructions Section Specifications and Installation Page Certifications Electrical SpecificationsTheory of Operation Catalytic Converter Dimensions Single Wall Oven Dimensions Double Wall Oven Installation Safety Instructions Installation Cabinet Dimensions and Specifications, Double Wall Oven Installing the Oven Double Wall Oven Cabinet DimensionsSingle Wall Oven Cabinet Dimensions Specifications and Installation Section Oven Controls and Cooking Speedcook Oven Page Speedcook Oven Controls Cook Modes Cooking a Recently Prepared Dish Favorites CookingRoast Toast Using the Microwave Function Using the Convection Bake FunctionUsing the Defrost Function Basic Cooking Mode 1 Oven OffMode 2 Select a Food Item Mode 6 Cooking Mode 3 Confirm SettingsMode 4 Preheat Mode 5 Ready to Cook Mode 9 Remove Food from Oven Mode 8 100% Complete Advanced Cook Mode Adjusting a Recipe’s Cook TimeAdjusting a Cook Temperature Saving to Favorites 495 Deleting a Dish from Favorites Reheat SettingSelf-Clean Mode Speedcook Oven Renaming a Dish in Favorites Section Oven Controls and Cooking Page Lower Oven Controls Convection Roast Warm SettingProof Setting Convection Bake 175 Sabbath Mode Self-Clean Mode Info Mode Page Adjusting Oven Sounds Overview of the Info Mode Adjusting the Oven’s Units & Measurements Adjusting Display Settings Backing Up/Restoring Favorites Updating the Oven Software Information Accessing the VersionInstaller Setup Oven Systems Page Convection System Speedcook Oven Speedcook Oven Door Convection System Lower OvenDouble Wall Oven Only Left Lock Motor Assembly Door Skin Replacement Measuring RF Leakage for Microwave Safety Right Lock Motor Assembly Lower Oven Door Double Wall Oven Only Halogen Light AssemblyRemoving/Reinstalling the Lower Oven Door High-Voltage Capacitors Halogen Bulb ReplacementMicrowave System Doubler Circuit, Voltage Waveguides High-Voltage TransformersMagnetrons CookWheel Control Control SystemClock Control Board EMI Filter Light Switch, Control PanelDisplay, Speedcook Oven Electrical Compartment Cooling Fans Magnetron Thermostats Power Supply, 12 VDCPower Supply, 24 VDC Magnetron Cooling Fan Relay K13 L2 Lower Heating Elements Double Wall Oven Only Selector SwitchesRelay K9 L2 Speedcook Heating Elements Relay K10 Lower Door Lock Gen 1 Oven Thermostat, Cooling Fan Control Temperature Switch Lower OvenSpeaker Transformer, Clock, 12 VAC Exhaust Blower Wiring HarnessExhaust System Catalytic Converter This page intentionally Left blank Troubleshooting Page Oven Door Open Gen Overview of TroubleshootingError Screens Cooling Fan Failure Gen Temperature Control Failure Blower Failure Magnetron Failure Control System Component Testing TroubleshootingOven Over Temperature If voltage is present, the oven mode switch RTD Cooling System Halogen Light System Troubleshooting Cooling Fans Gen Air Impingement System Microwave System Heating System, Speedcook Oven No Heat Turn the CookWheel to Bake to begin the preheat cycle Heating System, Lower Oven No Heat/Slow to Heat Testing for a K11 SSR that is Stuck Open This page intentionally Left blank Section Oven Schematics Page TDO Upper Oven TDO Bottom Oven Generation CT1 TDO2 Upper Oven Generation Relay Board REV D TDO2 Bottom Oven Generation TSO Oven Single Wall Oven RWD/RWS GEN 2 Control Board Pin-out descriptions Upper Left Upper Right This page intentionally Left blank Appendix Replacing Oven Components Page Part Details Locate the Part Here Comprehensive Table of Oven Components Appendix Replacing Oven Components Fuse, 20 Amp, Gen 100599 DWO Gen 100603 RTD A.16, A.17, A.18 Removing the Oven Component and Assembly Location, DWO Gen 1 and Gen None See pages -A.25 Bracket, USB, Strap RWS-9026 Component and Assembly Location, SWO Figure A.2 Component and Assembly Location, SWO Front Trim Assembly Removal Front Trim Assembly Detail Bracket, Display, Lower RWD-9142 Screw, #8 x 1/2, PHPH, PLT Bracket, Speaker RWD-9567 Control Housing Detail Differentiating Between DWO Gen 1 and DWO Gen Upper Electrical Compartment, DWO Gen Blower, Dual 104164 Screw, SH MTL, #8 x 1/2 Serrated Phtrh Appendix Replacing Oven Components Upper Electrical Compartment, DWO Gen 2 and SWO Appendix Replacing Oven Components Controls Assembly Detail, DWO Gen 1, DWO Gen 2, and SWO Figure A.11 Controls Assembly Detail, DWO Gen 2 and SWO Item Description Item Hardware Description Figure A.15 Relay Assembly Detail, DWO Gen Lower Electrical Compartment Detail, DWO Gen 1 and DWO Gen Figure A.19 Bracket, Relay Attachment Detail, Gen 104228 Screw, #6 x 1/2, PPHD, DRL-PT, SS 101687 Components Appendix Replacing Oven Components This page intentionally Left blank Lower Oven Cavity Component Detail, DWO Gen 1 and DWO Gen Figure A.25 Convection Fan Assembly Detail This page intentionally Left blank Page For service or information

Top Page Image Contents