Recommended Tools, Installing System Components | Dell SC440

Installing System Components

This section describes how to install the following system components:

•Front drive bezel

•Diskette drive

•Optical and tape drives

•Hard drives

•Expansion cards

•SAS controller card

•Memory

•Microprocessor

•Cooling fans

•System battery

•Power supply

•Chassis intrusion switch

•Bezel

•I/O panel

•System board

Recommended Tools

You may need the following items to perform the procedures in this section:

•#2 Phillips screwdriver

•Wrist grounding strap

Installing System Components

39

Image 39

Dell SC440 owner manual Recommended Tools, Installing System Components

Contents

W . d e l l . c o m s u p p o r t . d e l l . c o m Dell PowerEdge SC440 Systems September KH934 Contents Contents Contents Troubleshooting System Cooling Problems 107 Returning Items for Warranty Repair or Credit 109103 104 Contents About Your System Other Information You May Need Ctrl+S Accessing System Features During StartupDiagnostics on Information Front-Panel Features and Indicators Immediately after the power button is pressed Diagnostic Lights onReplaced Connecting External Devices Back-Panel Features and Indicators NIC Indicator Codes System Setup Program onYellow Mbps connection Orange Green About Your System Power Supply Indicators Diagnostic Lights System Messages Setup Program on Fan assembly is not installedReplace the battery. See System was opened Information only. To reset the chassis Expansion card System encountered a problemWhile trying to configure a PCIe For the same error Cannot send data to the associated Processor or hard drive Ensure that nothing is blockingSee Microprocessor on Diskette or hard-drive controller Cable might be loose Be faulty or improperly seatedSee Troubleshooting a Diskette Drive on Faulty Configuration Running the System Diagnostics onInsert a bootable diskette or CD From a nonbootable diskette or CD Enter the System Setup program Troubleshooting System Memory onAppears again, see Troubleshooting Boot device Restore system resources. If so, try Setup program, the operating systemMalfunctioning Running the System Diagnostics on Insert a diskette that has a bootable Getting Help on 91. If the problem persists, seeConfigured Faulty diskette drive or hard drive Diskette drive cannot read System clockMalfunctioning Diskette drive or hard drive Alert Messages Diagnostics Messages Responding to Error Messages Entering the System Setup ProgramNavigating the System Setup Program During System Setup Exiting the System Setup Program System Setup OptionsMain Screen Technology Express Service Code, and Asset TagSystem Options Description System Info Processor Info PCI Info Diskette drive defaultInternal default Dimm socket Integrated port is configured at 3E8h with IRQ4 On defaultDisables the ability to boot from a USB device Devices regardless of the No Boot setting System Password Not Set default Security Options Description Unlock SetupPassword Admin Password Not Set default Set Low Power Mode to Off On-Silent defaultExecute Disable Last default Load Defaults Maintenance Options Description Service TagSetup program Disabled Using the System Password Password Features Using the System Setup Program Press Enter to continue. The setting remains Set Using the Admin Password See Disabling a Forgotten Password on Disabling a Forgotten Password Recommended Tools Installing System Components Processor cooling fan Inside the System Closing the System Opening the System Removing the Front Drive Bezel Front Drive Bezel Removing an Insert on the Front Drive Bezel Replacing the Front Drive Bezel Diskette Drive Replacing an Insert on the Front Drive BezelRemoving the Diskette Drive Drive P7 Connector Floppy Installing a Diskette Drive Installing Diskette Drive Shoulder Screws Removing an Optical or Tape Drive Optical and Tape Drives IDE connector on system board Installing an Optical or Tape Drive Installing Optical or Tape Drive Shoulder Screws Hard Drive Installation Guidelines Hard DrivesRemoving a Hard Drive Drive bay Installing a Hard Drive 10. Installing a Hard Drive in a Drive Bracket Hard drive Sata data cable to hard drive Card Power cable to hard drive Auxled connector Removing an Expansion Card Expansion Cards Alignment guide Filler bracket Installing an Expansion Card SAS Controller Expansion Card Memory 512 MB None Memory Module Upgrade KitsMemory Module Installation Guidelines Memory Configuration Guidelines Total Memory Removing a Memory Module Installing a Memory Module Memory module socket ejectors Removing the Processor Microprocessor Processor cooling fan Installing System Components Release lever Cooling Fans Replacing the ProcessorRemoving the Cooling Fans Cpucage System Battery Removing the System BatteryReplacing the Cooling Fans Installing the System Battery Removing the Power Supply Power Supply Cable clamp Installing the Power Supply Removing the Chassis Intrusion Switch Chassis Intrusion Switch Installing the Chassis Intrusion Switch Removing the Bezel Bezel Replacing the Bezel Panel Assembly Screw on the I/O panel Installing System Components Removing the I/O Panel Assembly Replacing the I/O Panel Assembly System BoardRemoving the System Board Screws Installing System Components Installing the System Board Safety First-For You and Your System Start-Up RoutineChecking the Equipment Troubleshooting External Connections Troubleshooting IRQ Assignment Conflicts Monitor is not working properly Troubleshooting the Video SubsystemTroubleshooting the Keyboard Troubleshooting the Mouse Troubleshooting Basic I/O Problems Troubleshooting a Serial PortTroubleshooting a USB Device NIC cannot communicate with network Troubleshooting a NIC System was dropped or damaged Troubleshooting a Wet SystemTroubleshooting a Damaged System Liquid spilled on the system Excessive humidity Troubleshooting the System Battery Ensure that none of the following conditions exist Troubleshooting Power SupplyTroubleshooting System Cooling Problems Power-supply fault indicator is blinking amber Troubleshooting a Fan Troubleshooting System Memory Action Error message indicates a diskette drive problem Troubleshooting a Diskette Drive Troubleshooting an Optical Drive Troubleshooting an IDE Tape Drive Troubleshooting a Hard DriveAction Troubleshooting Your System Troubleshooting a SAS RAID Controller Troubleshooting Expansion Cards Action Troubleshooting the Microprocessor Troubleshooting Your System Using Dell PowerEdge Diagnostics System Diagnostics FeaturesRunning the System Diagnostics Using the Custom Test Options When to Use the System DiagnosticsRunning the System Diagnostics System Diagnostics Testing Options Selecting Devices for Testing Selecting Diagnostics OptionsViewing Information and Results 100 Jumpers and Connectors System Board Jumpers101 102 BootConfiguration settings in Nvram are cleared at next System boot 103 System Board Connectors Disabling a Forgotten Password 105 106 Getting Help Online ServicesObtaining Assistance 107 Electronic Quote Service AutoTech ServiceAutomated Order-Status Service Support Service 109 Before You Call 111 112 Contacting Dell Mail la-techsupport@dell.com General Support Getting Help 113Website support.ap.dell.com Country Code General Support 13DELL-133355 City Code General Support Toll-free 114 115 Mail la-techsupport@dell.com General Support 01-800-915-4755 116 117 General Support calling from Guayaquil3355 Mail la-techsupport@dell.com General Support 800-6132 118 119 120 121 Technical Support servers 122 Mail krsupport@dell.com 123 124 125 Fax 21 424 01 126 127 128 129 Mail delldirectsupport@dell.com Customer Care website International Access Code Country Code City Code130 Country City 131 132 Celsius 133Amperes AC Alternating current BTU British thermal unit Cm Centimeters Cmos Complementary metal-oxide semiconductor 134 Fahrenheit 135 LVD Low voltage differential Meters MA Milliamperes 136 137 System diskette See bootable diskette 138TCP/IP Transmission Control Protocol/Internet Protocol Volts VAC Volts alternating current VDC Volts direct current 139 140 Index Error messages, 27 systems management141 Dimm sockets Post 143 Index