Honeywell Official Replacement Parts Manual for SG Series
Page 74

Airport Systems

SECTION 6. REPLACEMENT PARTS

 

Description

 

Part Number

SGF-60 Flashhead

 

 

Capacitor, 1μF, C1-----------------------------------------------------

77-4220

Capacitor, 3μF, C4-----------------------------------------------------

77-3311

Capacitor, 12.5μF, C2 ---------------------------------------------

AC000003

Capacitor, 110μF, C3A

-----------------------------------------

77-4133-001

Capacitor, 50μF, C3B ----------------------------------------------

AC000002

Diode Block Assembly, DB1-------------------------------------

277-3342-6

Flashtube Assembly, V1----------------------------------------------

77-3295

Fuse, FNQ, 3.2A, F1

(for 480VAC) -----------------------------

77-2041

Fuse, FNQ, 6A, F1

(for 208/240VAC)------------------------

77-1167

Fuse, FNQ, 10A, F1

(for 120VAC) -----------------------------

77-2040

Fuse, FLA, 1/4A, F2

(for 120/208VAC)---------------------

FU000003

Fuse, FLA, 1/4A, F2

(for 240VAC) --------------------------

FU000003

Fuse, FLQ, 1/10A, F2

(for 480VAC) --------------------------

FU000004

PC Board, Motherboard --------------------------------------

277-5053-001

PC Board, Digital Controller, Programmed -------------

34E00031-001

PC Board, Trigger & High Voltage------------------------

34E00010-001

Relays K1, K2, K3------------------------------------------------------

77-3870

Transformer, T1 (60Hz)-----------------------------------------------

77-3890

Transformer, T1 (50Hz)---------------------------------------------

277-4244

Transformer, T2 (50Hz / 60Hz) ----------------------------------

TP000005

Trigger transformer --------------------------------------------------

277-3324

Power resistor---------------------------------------------------------

277-5101

Surge Arrestor ----------------------------------------------------------

77-4139

SGC-60 Master Controller

 

 

PC Board, Master Controller -------------------------------

34E00240-001

Transformer, T1 (50Hz / 60Hz) ----------------------------------

TP000005

Photocell---------------------------------------------------------

12H00107-001

SG-60 High Intensity Strobe System

6-1

Manual EPM-00000019 Rev A

Page 73 Page 75
Image 74
Page 73 Page 75
Contents Manual Number EPM-00000019-001 Union Place Simi Valley, CA Phone 805 Fax 805Rev Comment Approved DateDisclaimers Table of Contents Troubleshooting Maintenance Safety Information Qualified Personnel EPM-00000019-001 Vii Rev a Scope General DescriptionModel SGC-60 Master Controller Model SGF-60 Flashhead Safety Precautions Airport Systems Specifications Flashhead Fail System Configuration System Controls Power ConfigurationConfiguration Switches Airport Systems Condition 1 You have a Catenary System Flashtube Installation Flashtube Installation Setting the Flashhead Elevation Airport Systems Master Controller Mounting Dimensions Flashhead Outline and Mounting Dimensions Installation Wiring Typical Wiring InstallationRed wire Photocell Black wire PhotocellWhite wire Photocell Blue wireMaster Controller TB5-NO4 Controlling the Red Light SystemMaster Controller TB3-C4 Responding to Top Red Beacon Failures9LCA Alarm Card C1 9LCA Alarm Card NC1Flex Conduit Typical Installation Layout Procedures for installation of conduit and tower wiringAirport Systems Airport Systems Flex Conduit Installation Junction Box Wiring Details Flex Conduit Installation Detail Splicing Details for WC000001 Cable WC000001 Cable OverviewAirport Systems Airport Systems 10 Flashhead Cable 10 Master Controller Circuit Board 11 Flashhead Digital Control Board Final Installation Check Power Up and System Tests If SW2-2 is set for an External RED system ON, then If SW2-2 is set for no External RED system OFF thenDay Mode Twilight Mode Night ModeAirport Systems Airport Systems Airport Systems Overall Description SGF-60 FlashheadAirport Systems Airport Systems Power Supplies CommunicationsMode Selection Flash Control Flash FeedbackHigh Voltage Rectification Flashtube TriggeringSGC-60 Master Controller Airport Systems Airport Systems Master Controller Board Schematic SGF-60 Flashhead System Schematic SGF-60 Digital Board Schematic SGF-60 Trigger/High-Voltage Board Schematic Troubleshooting RLC General Troubleshooting All Flashheads Stuck in Day Mode General Troubleshooting Flashhead Does Not Flash General Troubleshooting Flashhead Stuck in Day Mode Dual System-Specific Troubleshooting Catenary System-Specific Troubleshooting Chart SGC-60 Replacement Transformer White wire to the outer bottom right terminal Flashtube Installation Ambient Light Sensor Photocell Replacement Parts Description Part NumberSG-60 AOL Power Supply Component Location SG-60 AOL Flashhead Mounting Dimensions SG-60 AOL Power Supply Mounting Dimensions SG-60 AOL Wiring Installation SG-60 AOL Flashhead Component Locations SG-60 AOL Power Supply Component Locations SG-60 AOL Schematic
Top Page Image Contents