Alamo DSEB-D16/SAS instruction manual Frame Stiiffener Kit

Page 33

Frame Rail Installation

Frame Rail Pre-Assembly: (continued)

Frame Rail Stiffener Kit (Crossmember). Shown below is the Frame Rail Stiffener Kit. This mounts under the Tractor and will be added to the Frame Rails during Assembly. Item 5 Rail Support Gussets are shipped loose and are not part of the Assembly, they will be bolted to the tractor and when instructed you will need to weld the Frame Rail Support to them (See Figure 2).

Frame Stiiffener Kit

Frame Rail, RH Shown

Frame Rail Stiffener Kit

(Crossmember)

3,4

5

1

2

Item

Part No.

Qty

Description

 

 

 

 

02970118

--

Frame Rail Stiffener Kit (Item 1 thru 4)

1

02970115

2

Rail Stiffener Weldment

2

02970086

1

Tube, Rail Stiffiner

3

02712500

4

Bolt, 1" NC X 4" GR8

4

5JRC1680

4

Locknut, 1" NC (Toplock)

5

02978499

2

Gusset Rail Support

Figure 2

A-Boom (JD 6615 / 7615 Asy Instruction Manual) 07/03

© 2003 Alamo Group Inc.

Section 4 - 4

Image 33
Contents John Deere 6615 BoomTo the OWNER/OPERATOR/DEALER Introduction Safety Section Operation Safety Index Assembly InstructionFilling Hydraulic Tank w/Oil 11-2 to Index Safety Section Safety 2003Alamo Group Inc SG-23 Death Components contain or emit chemicals known to the state Boom Paint Scraper to remove Paint before welding. Recommended Assembly Tools, Supplies and Equipment NeededFrame and Boom Saftey EquipmentHydraulic System Rotary Mower HeadFlail Mower Head Tractor Mower Operation InspectionPost-Operation Inspection Tractor Mower Component Location Wheel Weight Installation Rear Wheel Counter Weight Fill Left Rear Wheel with LiquidQty Description Installing Wheel Weight Alamo Group Inc Boom Front Pump Drive Shaft InstallationPump / Drive Assembly Instructions Installing Pump, Pump Drive Components and Hydraulic TankInstalling Pump Drive Components Drive Shaft Assembly Plate # 02976087 standard mount plate See Installing Pump Mount Plate & Tube End of DriveshaftInstalling Pump See Figure Install Front frame Rail Supports Alamo Group Inc Frame Rail / High Frame Setup / Pre- Assembly Installation Frame Rail Pre-Assembly Frame Rail Set UpFrame Rail Installation Frame Stiiffener Kit High Frame Mounting Tube Componnets High Frame Installation High Frame & King Post Asy Pre-Installing Frame Rails Front Frame Rail Mount Pad Support Mount Floor Jack Frame Rail Installation Pre-Installing High Frame 24-1/2 Min Height frame to Hood High Frame Frame Rail Section Item Part No Pre-Install Mounting Tubes for High FrameLine with Tack Welding Frame Rails Mounted the hole will be up. See Item Frame Recheck that all components are To the mounting Tube. See FigureRemove High Frame for Final Welding Remove High Frame for Welding Frame Rail Installation Alamo Group Inc Frame Rail & High Frame Final Installation Re-Install Frame Rails to Tractor Boom Rest See . Check that all Bolts and Nuts Are installed Frame Rail Installation 4 WDRe-Install High Frame to Tractor See Tighten LH & RH Side Frame Rail Hyd. Tank, CWT & Decal Final Installation Hyd. Tank CWT Installation Hydraulic Tank InstallationCounter Weight Installation Tank Decal Installation Decal InstallationTank Oil Level Sight Gauge Decal Part Number. See , 33Cab Decal Installation OFF Switch See FigureSide Window. See Figure Boom Installation Boom Installation Boom Installation / Boom HosesCutter Motor Control Valve Asy Attach Swing Pump / Tank Hose Installation Hose InstallationReturn Hose Pressure Gauge Alamo Group Inc Standard Cylinder Control Valve InstallationCylinder Control Valve Installation Control Handle Assembly InstallationController assemblies will be bolted On OFF Switch Installation Standard Control Valve Operation Common ProblemsSpool Valve Shown Cylinder Hydraulic Control Circuit See Figures 2 System SchematicCylinder Hydraulic Control Circuit See Mechanical Valve Models Cylinder Hydraulic Control CircuitCylinder Control Valve Installation Remote Cable Operation and Installation Tractor Front Control Assembly Controller End Installation ProcedureAlamo Group Inc Optional Joystick Wire Harness & Valve Installation Cushion Removed Three Existing Holes Optional Joystick MountingOption Joystick Mounting Installing Joystick Mount to Trac- tor SeatInstallingJoystick to Bracket Installing Wiring Harness for JoystickJoystick Mounting 2 WD & 4 WD Wire Harness Through Cab. There is a Align the Plug Guides Installing Wiring Harness to Joystick02967827 02965262 Installing Warning Instruction DecalsInstalling Wire Harness To Valve Wire Harness / Valve Mounting 2 WD & 4 WDTo Valve Installing Wire HarnessBOOM, Disregard this Section Joystick Plug Bottom of Joystick Console Joystick w/ Push/Pull Motor Switch & Rocker Master SwitchWire Harness Joystick Console Plug to Valve Control Valves See Figure Control Valve Electric / HydraulicAlamo Group Inc Head Installation Optional Heads Attaching Flail-Axe Head Optional Mower Head InstallationAttaching Flail Head Attaching Ditcher Head Alamo Group Inc Frame Square Head Attachment Fill Hydraulic Tank Fill Hydraulic Tank with Oil Fill Hydraulic TankFill Hydraulic Tank Alamo Group Inc Hydraulic Start-Up Procedures Start-up Instructions Post-Assembly Check List Alamo Group Inc Boom Rest Plate Boom Swing Stop Installation Boom Rest Plate installation Boom Rest Plate & Hook InstallationBoom Marked Here HereBolt on Boom Rest Hook Clamp Boom Swing Stop Installation Boom Swing Stop installationTack Weld Boom Swing Stop Lug. Tack Alamo Group Inc Alamo Group Inc Page Boom JD 6615 & JD7615 Assembly Manual Edition