IBM Partner Pavilion DS4100 specification

This product has been tested and found to comply with the limits for Class A Information Technology Equipment according to CISPR 22/European Standard EN 55022. The limits for Class A equipment were derived for commercial and industrial environments to provide reasonable protection against interference with licensed communication equipment.

Attention: This is a Class A product. In a domestic environment this product may cause radio interference in which case the user may be required to take adequate measures.

Taiwan Class A warning statement

Japanese Voluntary Control Council for Interference (VCCI) statement

130IBM TotalStorage DS4100 Storage Server: Installation, User’s, and Maintenance Guide

Image 162

IBM Partner Pavilion DS4100 manual

Contents

Installation, User’s, and Maintenance Guide Page Installation, User’s, and Maintenance Guide Page Safety Iii To Connect To Disconnect IEC 825-11993 Cenelec EN 60 Statement Safety Page Contents Cabling the storage server Operating the storage server Installing and replacing components Appendix B. Rack mounting template 131 Figures Page Tables Page Who should read this document About this documentFAStT product renaming Xvii How this document is organized DS4000 installation process overview Figures used in this document DS4000 Storage Server publications DS4500 storage server library About this document DS4400 storage server library DS4300 storage server library DS4100 storage server libraryPage DS4000-related hardware publications Power DS4000 Storage Manager Version 9 publications Before you call Getting information, help, and serviceUsing the documentation Web sites Software service and support Hardware service and supportFire suppression systems How to send your comments Page Introduction OverviewAbout the DS4100 base storage server About the DS4100 single-controller storage server Product updates Fibre channel definedSata defined Features at a glance Features at a glance Inventory checklist Clustering supportHardware Best practices guidelines Software and documentation Storage server components Front controls and indicators Hot-swap drive bays Front controls and indicators Back view RAID controller Hot-swap fans Interface ports and switches Hot-swap power supplies Ethernet port Server ID switch enclosure ID switchHost ports Expansion port Gbps/2 Gbps switch Storage server operating environment DS4100 specifications Heat output, airflow, and cooling Low Range High Range Hot aisle Installing the storage server Installation overviewUse safe practices when lifting Preparing for installation Handling static-sensitive devices Preparing the site Preparing the rack cabinet Installing the DS4100 Rack mounting template Front Installing the support rails Rear Alignment pins with and without spacers Rack flange type Pins to remove Installing the support rails Removing the CRUs Removing a RAID controller Removing a power supply Removing a fan Installing the DS4100 into a rack cabinet Removing a hard disk drive Installing the DS4100 Replacing the DS4100 CRUs Replacing a RAID controller Replacing a fan Setting the interface options Replacing a hard disk drive Fibre channel loop and ID settings Server ID enclosure ID settings Storage server speed settings Configuring the storage subsystemStorage subsystem management methods Direct out-of-band management method Fibre channel loop configurations Fibre channel connections Redundant host and drive loops Switch DS4100 DS4000 EXP100 Expansion unit Example of a two-cluster configuration base storage server Host Server Installing the storage subsystem configuration Installing the storage server Page Cabling the storage server Working with SFPs and fiber-optic cablesHandling fiber-optic cables Installing SFP modules Connect a fibre channel cable Installing fiber-optic cables Removing SFP modules Using LC-LC fibre-channel cables Removing caps from fiber-optic cables Connecting an LC-LC cable to an SFP module LC-LC fibre-channel cable Removing an LC-LC fibre-channel cable Removing fiber-optic cable protective caps Using LC-SC fibre-channel cable adapters LC-LC fibre-channel cable lever and latches Connecting an LC-SC cable adapter to a device LC-SC fibre-channel cable adapter Removing an LC-LC cable from an LC-SC cable adapter Removing the LC-SC cable adapter protective caps Connecting hosts to the RAID controllers Connecting hosts to a DS4100 base storage server Connecting secondary interface cables Location of host cables base storage server Connecting expansion units base storage server only Ethernet and serial port locationsPage Adding an expansion unit DS4000 EXP100 redundant loop configuration Power cabling Power cord locations Installing the DS4000 Storage Manager client Cabling the storage server Page Operating the storage server Turning the storage server on and off Turning on the storage server Turning off the storage server Restoring power after an unexpected shutdown Restoring power after an emergency shutdown Restoring power after an over-temperature shutdownPerforming an emergency shutdown Monitoring status through software Checking the LEDs Color Operating states1 Flashing every 5 seconds The drive has not Fault IconColor If the Ethernet connection is 10BASE-T If the Ethernet connection isIf there is no Ethernet connection Both Cache memory and RAID controller battery Cache memoryColor Operating states RAID controller cache battery Cache active LED Battery LED Page Installing and replacing components Working with hot-swap hard disk drives Installing hot-swap hard disk drives LED state Descriptions Hot-swap hard disk drive LEDs Replacing hot-swap hard disk drives Drive CRU handle Upgrading drives Adding larger-capacity drivesReplacing all the drives at the same time Replacing all drives at the same time Replacing the drives one at a time Installing and replacing components Replacing the drives one at a time Installing and replacing components Fan CRUs Fault LEDsWorking with hot-swap cooling fans Latches and handles Working with power supplies Power LED AC power switchesLevers Strain-relief clamp Removing a power supplyAC power connectors DS4100 single-controller storage server only Installing a power supply Lever for power supply removal Connecting the power cord to the AC power connector Cache battery is not included with the controller CRU Working with RAID controllers RAID controller levers and labels Replacing a RAID controller To replace a RAID controller, perform the following steps Unlocking the SFP module latch plastic variety Pull-rings for removing a controller Removing the controller battery Installing and replacing components Page Installing and replacing components Page Replacing the battery in the RAID controller Page Contains Sealed Lead Battery Must be Recycled Install the RAID controller, as shown in Figure Installing SFPs and fiber-optic cables Cabling the DS4100 to a redundant loop Solving problems Hardware maintenanceUsing the diagnostic hardware General checkout Symptom-to-FRU index Hardware maintenance Supplies. If applicable, check Parts listing Index DS4100 storage server FRU P/N FRU P/N Page Installed device records Appendix A. RecordsIdentification numbers Page Appendix B. Rack mounting template Front Appendix B. Rack mounting template Page Appendix C. Power cords 125 Islands, Cyprus, Dominica, Gambia, Ghana, Grenada Trademarks 127 Important notes Electronic emission noticesFederal Communications Commission FCC statement European Union EMC Directive conformance statement Avis de conformité à la réglementation d’Industrie CanadaPage Glossary See alsoAbstract Windowing Toolkit AWT. a Java graphical Auto-volume transfer/auto-disk transfer AVT/ADT DMA. See direct memory access Expansion port Eport. a port that connects Fibre Channel-Arbitrated Loop FC-AL. See GUI. See graphical user interface HBA. See host bus adapter Host computer. See host MIB. See management information base ODM. See Object Data Manager Peripheral component interconnect local bus PCI ROM. See read-only memory Simple Network Management Protocol SNMP. SNMP. See Simple Network Management Protocol and SNMPv1 Terminate and stay resident program TSR Transmission Control Protocol TCP. a Transmission Control Protocol/Internet ProtocolPage Index 141 129 Federal Communications Commission FCC Size Speed settings, setting Tray handle Unpacking Weight Gbic Readers’ Comments We’d Like to Hear from You How satisfied are you that the information in this book isPlease tell us how we can improve this book Business Reply Mail Page Part Number 25R0314