Briggs & Stratton 136200 manual Maintenance see figs. §¨, Maintenance Cont’d, Maintenance Schedule

Page 17

GB

Maintenance (see figs. ¦§¨)

Also, see Maintenance Schedule. Follow the hourly or calendar intervals, whichever occur first. More frequent service is required when operating in adverse conditions.

To prevent acci- dental starting, re- move spark plug

wire ™ and ground it before servicing, and disconnect battery at negative terminal, if equipped.

Oil service (see fig. ¦)

Check oil level regularly.

Be sure correct oil level is maintained. Check every 5 hours or daily, before starting engine. See oil filling procedure, Oil Recommendations.

Change oil.

Change oil after first 5 hours of operation. Change oil while engine is warm. Refill with new oil of recom-

mended SAE viscosity grade. (see fig. ©)

Gear reduction, if equipped

Remove oil fill plug š and oil level plug ›. Drain oil every 100 hours of operation or every season. To refill, pour SAE 30 oil into oil fill hole until it runs out level check hole. Replace both plugs. Oil fill plug has a vent hole œ and must be installed on top of gear case cover.

Air cleaner service (see fig. §)

Replace pre-cleaner š, if equipped, and/or cartridge › if very dirty or damaged.

1.Loosen screws or remove knob. Then remove cover.

2.Remove pre-cleaner, if equipped, and cartridge carefully to prevent debris from falling into carburetor.

To service pre-cleaner, wash in liquid detergent and water. Squeeze dry in a clean cloth. Saturate in engine oil. Squeeze in clean, absorbent cloth to remove ALL EXCESS oil.

To service cartridge, clean by tapping gently on a flat surface. Do not use petroleum solvents, e.g., kerosene, which will cause cartridge to deteriorate. Do not use pressurized air, which can damage cartridge. Do not oil cartridge.

3.Reinstall cartridge and pre-cleaner, if equipped.

4.Replace cover and tighten screws or knob securely.

Maintenance Cont’d

Spark plug service (see fig. ¨)

DO NOT check for spark with spark plug removed.

Use only Briggs & Stratton Spark Tester š, to check for spark.

DO NOT crank engine with spark plug removed. If engine is flooded, place throttle in FAST and crank until engine starts.

Spark plug gap › should be .76 mm or 0.030 in. Clean/replace spark plug every 100 hours or every season, whichever occurs first. Spark plug wrench is available from any Authorized Briggs & Stratton Service Dealer.

Note: In some areas, local law requires using a resistor spark plug to suppress ignition signals. If this engine was originally equipped with resistor spark plug, use same type of spark plug for replacement.

Keep engine clean (see fig. ¨)

Periodically remove chaff and debris build-up from engine. Clean finger guard. Do not spray engine with water to clean because water could contaminate fuel. Clean with a brush or compressed air.

Accumulation of debris around muf-

fler œ could cause a fire. Inspect

and clean before every use.

To assure smooth operation, keep governor linkage, springs and controls free of debris.

If muffler is equipped with spark arrester screen , remove spark arrester screen for cleaning and inspec- tion every 50 hours or every season. Replace if damaged.

Clean cooling system. Chaff or debris may clog engine’s air cooling system, especially after prolonged operation. Internal cooling fins and surfaces may require cleaning to prevent overheating and engine damage. Remove blower housing and clean as shown ž.

Maintenance Schedule

Follow the hourly or calendar intervals, whichever occur first. More frequent service is required when operating in adverse conditions noted below.

First 5 Hours

DChange oil

Every 5 hours or daily

D Check oil level

D Clean finger guard D Clean around muffler

Every 25 hours or every season

DChange oil if operating under heavy load or high ambient temperature

DService air cleaner pre-cleaner, if equipped* D Service air cleaner cartridge if no pre-cleaner*

Every 50 hours or every season

DChange oil

DClean and inspect spark arrester, if equipped.

Every 100 hours or every season

DService air cleaner cartridge if equipped with pre-cleaner*

DReplace/clean spark plug

DChange oil, gear reduction, if equipped D Clean cooling system*

*Clean more often under dusty conditions,or when airborne debris or chaff is present.

Partial List of Genuine Briggs & Stratton Parts

Briggs & Stratton (or equivalent)

Part

Part No.

Oil (20 oz.)

. . . 100005

Oil (48 oz.)

. . . 100028

Oil pump kit (uses standard electric drill

. . . . . 5056

to remove oil from engine quickly)

 

Fuel stabilizer (1 oz., 30 ml single use pouch) 992030 Fuel stabilizer (4.2 oz., 125 ml bottle) 999005E (5041)

Flat air cleaner cartridge

491588

(5043)

Flat air cleaner pre-cleaner

. . . . . 491435

Resistor spark plug

. . . . 802592E

Standard spark plug

. . . . . 492167

Long life platinum spark plug

992041

(5062)

(used on most L-head engines)

 

 

Spark tester

. . . . . .

19368

Spark plug wrench

. 89838

(5023)

Spark arrester . . . . . . . . . . . . . . . . . . . . . . 399541

4

Page 16 Page 18
Image 17
Page 16 Page 18
Contents Form NO. MS-6328-7/00 Copyright 2000 by Briggs & Stratton CorporationInternationale symboler og forklaringer Håndbogens symbolerMotorkomponenter se fig. ¡ SikkerhedsforskrifterNÅR Motoren Startes Påfyldning AF BrændstofBetjening AF Redskabet Transport AF RedskabetStandsning af motoren se fig. ¤ Justeringer se fig. ¥Anbefalinger vedr. olie se fig Anbefalinger vedr. brændstofVedligeholdelse fortsat Vedligeholdelse se fig. §¨Vedligeholdelsesoversigt SAE type se figEftersyn OpbevaringSkift olie. Se Olieeftersyn se fig Tilsvarende rubrikkerGarantibevis for ejere af Briggs & Stratton-motorer MotorgarantiBegrænset Garanti GarantiperiodeHet Gebruik Van De HandleidingFiguren Internationale Symbolen en Beteke- nissenMotor Onderdelen zie fig. ¡ Veiligheid VoorzorgenBIJ HET Starten VAN DE Motor BIJ HET Toevoegen VAN BrandstofBIJ HET Gebruik VAN DE Machine BIJ HET Transporteren VAN DE MachineAfstellingen zie fig. ¥ Olie Aanbevelingen zie figBrandstof Aanbevelingen Onderhoud zie fig. §¨ Onderhouds SchemaOnderhoud Vervolg Zie fig Olie verversen. Zie Olie ServiceOpslag Briggs & Stratton Motor Eigenaar Garantie Politiek Over Uw Motor GarantieGarantiebepalingen GarantieperiodeHow To Use Manual Figures Engine Components see fig. ¡ Safety Precautions¡ -- ¨refer to figures inside covers Engine Model Type XxxxxxWhen Starting Engine When Adding FuelWhen Operating Equipment When Transporting EquipmentFuel Recommendations Adjustments see fig. ¥Oil Recommendations see fig Starting see figs. ¡¢£Maintenance Schedule Maintenance see figs. §¨Maintenance Cont’d Service Dealers worldwide, including ServiceChange oil. See Oil service. see figs StorageBriggs & Stratton Engine Owner Warranty Policy About Your Engine WarrantyLimited Warranty Warranty PeriodMoottorin komponentit Käsikirjan numeroinnitTurvallisuusohjeet SetMoottoria Käynnistettäessä Polttoainetta LisätessäLaitetta Käytettäessä Laitetta KuljetettaessaPolttoainesuositukset Öljysuositukset ks. kuvaKäynnistys ks. kuvat ¡¢£ Pysäytys ks. kuva ¤Huoltokaavio Kunnossapito ks. kuvat §¨Kunnossapito, jatkoa Huolto VarastointiVaihda öljyt. Katso kohtaa Öljyhuolto ks. kuvia Bensiini TaiBriggs & Stratton -moottorin omistajan takuukirja Tietoja moottorin takuustaRajoitettu Takuu TakuuaikaPièces du moteur voir Fig. ¡ Comment utiliser les illustrations du manuelConsignes de sécurité Modèle Type CodeHuiles recommandées voir Fig Carburants recommandésGauche avec SJ/CF Energy Contrôle du niveau d’essencePage Démarrage voir les Fig. ¡¢£ Huiles recommandéesArrêt voir Fig. ¤ Réglages voir Fig. ¥Stockage Service Après-VenteProgramme d’entretien Durée de la couverture Pièces sous garantieGarantie Limitee Propos de la garantie de moteurPeriode DE Garantie AUX U.S.A. ET AU CanadaSicherheitsvorkehrungen Bedienungssymbole und ihre AnwendungMotorkomponenten siehe Abb. ¡ TungenBeim Start DES Motors Beim Einfüllen VON KraftstoffBEI Betrieb DES Geräts Beim Transport DES GerätsEmpfehlungen zum Kraftstoff Empfehlungen zum ÖlEinstellungen siehe Abb. ¥ Wartungsplan Wartung, FortsWartung siehe Abb. §¨ Ölwechsel siehe AbbAls 30.000 Vertragshändlern ein LagerungGeboten wird, auf diese Zeichen Ähnlichen KategorieBriggs & Stratton-Garantieschein für Motorbesitzer Zur MotorgarantieBeschränkte Garantie GarantiefristÍá ñçóéìïïéóåôå ôéò Åîáñôìáôá êéíçôñá Ñïåéäïïé ÓõóôÜóåéò ãéá ôï ëÜäé Óõíôñçóç âë å åéê. §¨ Óõíôñçóç óõíåéá Áïèêåõóç ÓåôéêÜ ìå ôçí åããçóç ôïõ êéíçôñá óáò Page Componenti del motore Come utilizzare le Figure del manualePrecauzioni di sicurezza Simboli di pericolo e relativo signifi- catoALL’AVVIAMENTO DEL Motore Durante IL Rifornimento DEL CarburanteDurante L’USO DELL’ATTREZZATURA Durante IL Trasporto DELL’ATTREZZATURARaccomandazioni per l’olio Raccomandazioni per il carbu- ranteProgramma di manutenzione Manutenzione continuaManutenzione vedere fig. §¨ Consigliato vedere figAssistenza RimessaggioCambiare l’olio. Vedere Cambio dell’olio vede- re fig Sistenza Autorizzati in tutto il mondoGaranzia Limitata Polizza di garanzia relativa ai motori Briggs & StrattonPeriodo DI Garanzia A. E CanadaInternasjonale symboler og betydning Faresymboler og betydningHvordan figurene i håndboken skal brukes SikkerhetstiltakPåfylling AV Drivstoff Testing AV GnistStart AV Motoren Bruk AV MaskinenStopp se fig. ¤ Anbefalt olje se figAnbefalt drivstoff Vedlikeholdsplan Vedlikehold se fig. §¨Vedlikehold. Forts Eller liknende Skift olje. Se oljeservice se figLagring/oppbevaring Begrenset Garanti Vedrørende garanti på motorenBriggs & Stratton motorgaranti Componentes do motor Como consultar as figuras do manualMedidas de segurança Símbolos de perigo e significadosQuando DER Partida no Motor Quando Acrescentar CombustívelQuando Operar O Equipamento Quando Transportar O EquipamentoFim de parar o motor ver Fig. ¤ Recomendações de ÓleoRecomendações de combustível Manutenção ver Figs. §¨ ManutençãoPrograma de manutenção Troque o óleo. Ver Verificação de óleo ver Figs ArmazenagemMais de 30000 Centros de Serviço Pre que lhe oferecem serviços Briggs & StrattonGarantia Limitada Sobre a garantia do seu motorPeríodo DE Garantia Fora DOS E.U.A. E Canadá MotoresPrecauciones de Seguridad Componentes del MotorCómo Usar las Figuras del Manual Símbolos Internacionales y SignificadosCuando DE Arranque AL Motor Cuando Añada CombustibleCuando Opere EL Equipo Cuando Transporte EL EquipoParada ¤ Recomendaciones para elRecomendaciones para el Combustible Programa de Mantenimiento MantenimientoMantenimiento Continuación Vea las figuras §¨Servicio BodegajeCentros de Servicio Autorizados a nivel Ofrezca servicio Briggs & StrattonMantenimiento Incorrecto Acerca de la Garantía de Su MotorMotordelar se fig. ¡ Internationella symboler och innebörderSäkerhetsåtgärder Så här används siffrorna i handbokenVID Start VID BensinpåfyllningVID Drift VID Transport AV UtrustningenBränslerekommendationer Justeringar se fig. ¥Oljerekommendationer se fig Inte, se JusteringarUnderhåll se fig. §¨ UnderhållsschemaUnderhåll, forts Olja se figByt olja. Se Olja se fig Auktoriserade servicecentraFörvaring Garantiperiod Begränsad GarantiNormal förslitning Felaktigt underhåll
Related manuals
Manual 57 pages 30.97 Kb Manual 12 pages 55.29 Kb Manual 10 pages 41.51 Kb Manual 30 pages 50.01 Kb

134200, 137200, 133200, 136200, 135200 specifications

The Briggs & Stratton 136200 is a powerful and reliable small engine that is engineered to deliver exceptional performance and durability for a variety of applications. This versatile engine is a popular choice among outdoor power equipment manufacturers due to its robust features and advanced technologies.

One of the standout characteristics of the Briggs & Stratton 136200 is its 5.5 horsepower output, which is capable of powering lawn mowers, pressure washers, and other equipment. The engine operates with a displacement of 142cc, providing a great balance between power and fuel efficiency. Users can expect a long service life, thanks to the engine's rugged construction and high-quality materials.

The engine features a reliable overhead valve (OHV) design, which enhances fuel efficiency while optimizing the combustion process. This design contributes to lower emissions, making the Briggs & Stratton 136200 environmentally friendly. The OHV configuration also provides improved thermal regulation, resulting in better performance in various operating conditions.

Equipped with a ReadyStart system, the engine simplifies starting. This technology eliminates the need for a manual choke, allowing for effortless starting even in cold weather. Users appreciate the convenience of the automatic primer system, which ensures the correct amount of fuel reaches the combustion chamber with minimal effort.

Another key feature of the Briggs & Stratton 136200 is its low oil shutdown mechanism. This safety feature automatically stops the engine when the oil level becomes too low, preventing potential damage and prolonging the engine's lifespan. Additionally, the engine is designed for easy maintenance, with easily accessible components that allow for quick oil changes and tune-ups.

Furthermore, the built-in dual air cleaner system enhances filtration and ensures the engine operates smoothly, regardless of the dust and debris in the environment. This attention to air quality contributes to improved overall engine performance and longevity.

In summary, the Briggs & Stratton 136200 is a well-engineered small engine that combines power, efficiency, and convenience, making it an excellent choice for various outdoor equipment applications. Its advanced technologies, user-friendly features, and durable design position it as a trusted option for both manufacturers and end-users alike. Whether for residential lawn care or commercial cleaning tasks, the 136200 continues to prove its worth in the field.
Top Page Image Contents