Software Version December
Cisco 11500 Series Content Services Switch
Hardware Installation Guide
Cisco Systems, Inc 170 West Tasman Drive San Jose, CA
Turn the television or radio antenna until the interference stops
Move the equipment farther away from the television or radio
Copyright 2002, Cisco Systems, Inc All rights reserved
Page
Symbols and Conventions
C O N T E N T S
Electrical Safety
Unpacking and Installing the CSS
Preinstallation Requirements
Installing a Module
Shipment Contents
Installing the CSS 11501
Booting and Configuring the CSS
Connecting the Power Cord
Checking the DC Power Connection CSS 11503 and CSS 11506
Booting the CSS for the First Time
Cable Connector Pinouts B-1
RS-232 Console Port Pinouts B-3
Troubleshooting C-1
Safety Requirements D-9 Laser Safety D-10 Translated Safety Warnings
Contents
Fan Injury Warning D-39 AC and DC Power Module Warning D-40
Power Cord Warning other versions available D-41
Ground Conductor Warning
Contents
78-13884-03
CSS 11501 Connectors and LEDs
Front-Mounting Position of the CSS 11506 Mounting Brackets
SSL Module LEDs
xiii
Figure C-2
Location of the CSS 11506 Power Supplies C-13
Figure C-1
Figure C-3
Session Accelerator Module LED Descriptions
RJ-45 Fast Ethernet Connector Pinouts B-2
RJ-45 RS-232 Serial Connector Pinouts for the Console Port B-3
Table A-1
Table B-5
Table B-3
Table B-4
Table B-6
xvii
About This Guide
Audience
Booting and
How to Use This Guide
Installing the CSS
Configuring the CSS
Description
Related Documentation
Document Title
Document Title
Description
Description
Symbols and Conventions
Document Title
Varoitus Tämä varoitusmerkki merkitsee vaaraa. Olet tilanteessa, joka voi johtaa ruumiinvammaan. Ennen kuin työskentelet minkään laitteiston parissa, ota selvää sähkökytkentöihin liittyvistä vaaroista ja tavanomaisista onnettomuuksien ehkäisykeinoista. Tässä julkaisussa esiintyvien varoitusten käännökset löydät tämän laitteen mukana olevan asennusoppaan liitteestä Translated Safety Warnings käännetyt turvallisuutta koskevat varoitukset
xxii
Warnung Dieses Warnsymbol bedeutet Gefahr. Sie befinden sich in einer Situation, die zu einer Körperverletzung führen könnte. Bevor Sie mit der Arbeit an irgendeinem Gerät beginnen, seien Sie sich der mit elektrischen Stromkreisen verbundenen Gefahren und der Standardpraktiken zur Vermeidung von Unfällen bewußt. Übersetzungen der in dieser Veröffentlichung enthaltenen Warnhinweise finden Sie im Anhang mit dem Titel “Translated Safety Warnings” Übersetzung der Warnhinweise in der diesem Gerät beiliegenden Installationsanleitung
xxiii
xxiv
Obtaining Documentation
World Wide Web
Documentation Feedback
Documentation CD-ROM
Ordering Documentation
Technical Assistance Center
Obtaining Technical Assistance
Cisco.com
xxvi
xxvii
Cisco TAC Web Site
Priority level 4 P4 product capabilities
Cisco TAC Escalation Center
xxviii
Shipment Contents Unpacking the CSS If the Product is Damaged
Unpacking and Installing the CSS
Site Requirements Safety Guidelines Required Tools and Equipment
Preinstallation Requirements Installing the CSS Installing the CSS
Safety Guidelines
Site Requirements
Chassis-Lifting Guidelines for the CSS 11503 and CSS
Chapter 1 Unpacking and Installing the CSS Safety Guidelines
Electrical Safety
Never install telephone wiring during a lightning storm
Table 1-2 DC Electrical Specifications
Specifications for Cisco 11500 Series Power Supplies
Table 1-1 AC Electrical Specifications
Power Guidelines for DC Systems CSS 11503 and CSS
Required Tools and Equipment
Shipment Contents
Unpacking the CSS 11503 or CSS
Unpacking the CSS
Unpacking the CSS
Unpacking the CSS Unpacking the CSS 11503 or CSS
If the Product is Damaged
1-10
1-11
Preinstallation Requirements
Installing the CSS Installing the CSS Installing the CSS
Installing a CSS 11501 as a Freestanding Unit
Installing the CSS
Installing a CSS 11501 as a Freestanding Unit
Installing a CSS 11501 as a Rackmounted Unit
Installing a CSS 11501 as a Rackmounted Unit
1-13
Installing a CSS 11503 as a Freestanding Unit
Installing a CSS 11503 as a Freestanding Unit
Installing the CSS
Installing a CSS 11503 as a Rackmounted Unit
Figure 1-2 Front-Mounting the Mounting Brackets on the CSS
Installing a CSS 11503 as a Rackmounted Unit
1-15
1-16
Figure 1-3 Mid-Mounting the Mounting Brackets on the CSS
Rack-Mounting the CSS 11506 Chassis
Installing the CSS
Mid-Mounting the CSS 11506 Mounting Brackets
1-17
Figure 1-5 Mid-Mounting the Mounting Brackets on the CSS
Mid-Mounting the CSS 11506 Mounting Brackets
1-18
Installation Precautions and Restrictions Unpacking a CSS Module
Installing a CSS Module
Rack-Mounting the CSS 11506 Chassis
Installing a Module Installing a Module
1-20
Installation Precautions and Restrictions
Installation Precautions
Table 1-3 CSS 11503 Chassis Slot Restriction
Module Slot Restrictions
1-21
Table 1-4 CSS 11506 Chassis Slot Restriction
Slot location
Figure 1-6 Fully-Configured CSS
Chapter 1 Unpacking and Installing the CSS Installing a CSS Module
Slot location
1-23
Figure 1-7 Fully-Configured CSS
Chapter 1 Unpacking and Installing the CSS Installing a CSS Module
78-13884-03
1-24
Installing a Module
Unpacking a CSS Module
To install a module
1-25
Installing a Passive SCM in a CSS
1-26
9. Reboot the CSS to initialize the passive SCM
1-27
78-13884-03
Chapter 1 Unpacking and Installing the CSS Installing a CSS Module
1-28
Connecting the Power Cord
Cabling the CSS
Connecting the Console Connecting the Chassis to Ground
C H A P T E R
Cabling the CSS
Two status module LEDs indicating power and device readiness
CSS 11501 Connectors and LEDs
State
LED Name
Color
Indicates
State
LED Name
Color
Indicates
Fast Ethernet Module Connectors and LEDs
CSS 11503 and CSS 11506 Module Overview
Switch Control Module Connectors and LEDs
Gigabit Ethernet Module Connectors and LEDs
The CSS modules are as follows
An additional SCM to serve as a passive redundant module
2-10
Figure 2-3 CSS 11506 Content Services Switch
2 3 4
Chapter 2 Cabling the CSS Cabling the CSS 11503 and CSS 11506 Modules
Switch Control Module Connectors and LEDs
2-11
Figure 2-4 Switch Control Module Connectors and LEDs
2-12
Color
Table 2-2 Switch Control Module LED Descriptions
LED Name
State
2-14
Fast Ethernet Module Connectors and LEDs
Figure 2-5 8-Port Fast Ethernet Module Connectors and LEDs
10M-16FE
Figure 2-6 16-Port Fast Ethernet Module Connectors and LEDs
2-15
Ethernet
Table 2-3 Fast Ethernet Module LED Descriptions
Gigabit Ethernet Module Connectors and LEDs
2-16
Table 2-4 Gigabit Ethernet Module LED Descriptions
Figure 2-7 Gigabit Ethernet Module Connectors and LEDs
2-17
C S S 5 - 1 0 M - 2 G E
Table 2-4 Gigabit Ethernet Module LED Descriptions continued
Session Accelerator Module LEDs
2-18
Figure 2-8 Session Accelerator Module LEDs
Table 2-5 Session Accelerator Module LED Descriptions
Secure Socket Layer SSL Module LEDs
2-19
State
LED Name
Color
Indicates
Parameters
Connecting the Console
Default Settings
2-21
2-22
Connecting the Chassis to Ground
Tools and Supplies
1 or
2-23
2-24
Attaching the Grounding Cable
Strip Length
2-25
8. Go to the next section, “Connecting the Power Cord”
Figure 2-10 Attaching Grounding Wire to Grounding Lug
Connecting a CSS 11501 Power Cord Connecting a CSS 11503 Power Cord
Connecting the Power Cord
Connecting a CSS 11501 Power Cord
Connecting a CSS 11506 Power Cord
Connecting a CSS 11503 AC Power Cord
Connecting a CSS 11503 Power Cord
Connecting a CSS 11503 AC Power Cord
Connecting a CSS 11503 DC Power Cord
Connecting a CSS 11503 DC Power Cord
2-28
48/-60V
Figure 2-13 Location of the CSS 11503 DC Power Supply Connectors
2-29
0A,430VA
Table 2-9 CSS 11503 to DC Power Source Cabling
2-30
Connecting a CSS 11506 AC Power Cord
Connecting a CSS 11506 Power Cord
Connecting a CSS 11506 AC Power Cord
Connecting a CSS 11506 DC Power Cord
Figure 2-14 Connecting a CSS 11506 AC Power Cord
2-32
Connecting a CSS 11506 DC Power Cord
2-33
I/P DC
Figure 2-15 Location of CSS 11506 DC Power Supply Connectors
2-34
OK OK
Table 2-10 CSS 11506 to DC Power Source Cabling
2-35
Checking the DC Power Connection CSS 11503 and CSS
2-36
Powering Up the CSS Powering Down the CSS
Booting and Configuring the CSS
Powering Up the CSS
Booting the CSS for the First Time Logging in to the CSS
Powering Down the CSS
Booting the CSS for the First Time
Booting the CSS for the First Time
Hardware Initialization and Power-On Diagnostics
Chapter 3 Booting and Configuring the CSS
LED Color
Table 3-1 Status LEDs Boot Definitions
State Sequence
LED State
Entering Your License Key
Configuring the Ethernet Management Port
Changing the Default Username and Password
Confirm administrator password
Password-Protecting the Offline Diagnostic Monitor Menu
Enter administrator username Enter administrator password
Set Password Protection for Offline Diagnostic Monitor menu yes,no
Logging in to the CSS
Using the Configuration Script
3-10
Chapter 3 Booting and Configuring the CSS
Configuring Layer 3 Load Balancing Configuring Layer 5 Load Balancing
Configuring Proxy Cache Configuring Transparent Cache
Using the Configuration Script
Configuring Layer 3 Load Balancing
3-12
Displays the running-config
To configure Layer 3 load balancing, enter
After the configuration is completed, the script automatically
Saves the running-config to the startup-config
Configuring Layer 5 Load Balancing
3-14
The script prompts you to configure
3-15
vip address 192.168.3.8 balance aca active content L5Rule
Configuring Proxy Cache
owner L5Owner content L3Rule
3-16
The script prompts you to configure
3-17
Configuring Transparent Cache
3-18
Activates the services
3-19
Saves the running-config to the startup-config
After the configuration is completed, the script automatically
Displays the running-config
Chapter 3 Booting and Configuring the CSS
Using the Configuration Script
Where to Go Next
Chapter 3 Booting and Configuring the CSS
owner TransparentOwner content TransparentRule
3-22
Chapter 3 Booting and Configuring the CSS
Using the Configuration Script
78-13884-03
Physical Specifications Module Specifications Disk Specifications
Specifications
Electrical Specifications Environmental Specifications
A P P E N D I X A
Electrical Specifications
Environmental Specifications
Physical Specifications
Module Specifications
Disk Specifications
Network
Supported Standards
Transport
Application
Routing
Gateway
Network Utilities
78-13884-03
Network Management
Appendix A Specifications Supported Standards
RJ-45 RS-232 Console Port Pinouts RJ-45 Management Connector Pinouts
Cable Connector Pinouts
RJ-45 Fast Ethernet Connector Pinouts
A P P E N D I X B
RJ-45 Fast Ethernet Connector Pinouts
Connecting the Console Port to a Terminal
RJ-45 RS-232 Console Port Pinouts
Connecting the Console Port to a PC
Connecting the Console Port to a Modem
Connecting the Console Port to a PC
Connecting the Console Port to a Terminal
Connecting the Console Port to a Modem
Appendix B Cable Connector Pinouts RJ-45 Management Connector Pinouts
RJ-45 Management Connector Pinouts
Table B-6 RJ-45 Management Connector Pinouts
78-13884-03
Appendix B Cable Connector Pinouts RJ-45 Management Connector Pinouts
78-13884-03
Troubleshooting the Console Interface
Troubleshooting
Troubleshooting the Boot Process
Troubleshooting the CSS Power Supply Troubleshooting the CSS Fans
Diagnostic Tests for Hardware
Troubleshooting the Boot Process
Diagnostic Tests for Hardware
OffDM Verification of the Boot Configuration Record and Disk
Test Ref # Testreference
From Slot Slotnumber, CPU Cpunumber Level Failurelevel
Type Failuretype
Failuredetails
Field
Description
Description
Table C-1 Fields in the Diagnostic Monitor Error Message continued
Field
Page
Errors in the Boot Configuration Record
OffDM Verification of the Boot Configuration Record and Disk
Errors in the Boot Configuration Record
Failure of the Disk Drive in the SCM
CSS 11501 Boot and Verification
Failure of the Disk Drive in the SCM
SCM Boot and Verification of the Modules
Troubleshooting the Console Interface
C-10
Troubleshooting the CSS 11501 Power Supply
Troubleshooting the CSS Power Supply
Troubleshooting the CSS 11501 Power Supply
Troubleshooting the CSS 11503 Power Supply
C-12
Troubleshooting the CSS 11503 Power Supply
Troubleshooting the CSS 11506 Power Supply
CHMGR Missing backup power supply
Figure C-1 Location of the CSS 11506 Power Supplies
Appendix C Troubleshooting Troubleshooting the CSS Power Supply
CHMGR Cannot locate power supply PSnumber
Appendix C Troubleshooting Troubleshooting the CSS Power Supply
Figure C-2 CSS 11506 AC Power Supply LEDs
Figure C-3 CSS 11506 DC Power Supply LEDs
POWER SOURCES
I/P OK DC power supply
C-15
Troubleshooting the CSS 11501 Chassis Fans
Troubleshooting the CSS Fans
Troubleshooting the CSS 11501 Chassis Fans
Troubleshooting the CSS 11503 Chassis Fans
Troubleshooting the CSS 11503 Chassis Fans
C-17
Troubleshooting the CSS 11506 Fan Module
C-18
C-19
Troubleshooting the CSS
Information”
C-20
Troubleshooting the CSS Modules
C-21
Table C-5 Troubleshooting the CSS Modules
C-22
Table C-5 Troubleshooting the CSS Modules continued
C-23
Log File Information
C-24
C-25
Table C-6 CSS Log File Descriptions continued
78-13884-03
Appendix C Troubleshooting Log File Information
C-26
Agency Approvals Safety Requirements Translated Safety Warnings
A P P E N D I X D
Agency Approvals
FCC Class A Compliance Notice United States
FCC Compliance Information Statement United States
CISPR 22 Class A Warning
ICES-003 Class A Compliance Notice Canada
Europe EU
VCCI Class A Warning
Page
Class A Notice for Taiwan and Other Traditional Chinese Markets
Class A EMC Warning
Safety Requirements
D-10
Laser Safety
Safety Requirements
78-13884-03
D-11
Translated Safety Warnings
Warning Definition
D-12
Lithium Battery Disposal Warning
D-13
Radiation from Open Port Aperture Warning
D-14
D-15
D-16
Class 1 Laser Product Warning
Qualified Personnel Warning
Two-Person Lifting Warning
D-17
D-18
Lightning Activity Warning
D-19
Jewelry Removal Warning
D-20
Reading Instructions Warning
D-21
Disconnect Device Warning
D-22
Chassis Installation Warning
D-23
monteringsskruene
eine dritte Person die Befestigungsschrauben festzieht
personer må holde kabinettet på plass mens en tredje person fester
pessoa para apertar os parafusos de montagem
Ground Conductor Warning
D-25
Installation and Replacement Warning
D-26
Use Copper Conductors Only
D-27
Short-Circuit Protection Warning
D-28
Wire Preparation Warning
D-29
D-30
DC Power Source Warning
D-31
D-32
Dual Power Supply Warning
D-33
DC Power Supply Wiring Warning
D-34
D-35
Blank Faceplate Requirement Warning
D-36
D-37
Power Off Before Working on System Warning
D-38
Fan Injury Warning
D-39
AC and DC Power Module Warning
D-40
Power Cord Warning other versions available
D-41
Ground Conductor Warning
D-42
Translated Safety Warnings
D-43
78-13884-03
Translated Safety Warnings
D-44
I N D E
IN-1
IN-2
DC electrical specifications 1-6, A-2
configuring
IN-3
IN-4
IN-5
78-13884-03
IN-6
Index