BATTERIES
SECTION 9 | BATTERIES |
|
|
This Section Includes the Following:
Warnings for Handling and Replacing Batteries
Using the Proper Batteries
Installing/Removing Batteries Into/From Battery Boxes
Disconnecting/Connecting Battery Cables
When to Charge Batteries
Charging Batteries
Replacing Batteries
Removing/Installing Battery Boxes
WARNINGS FOR HANDLING AND REPLACING BATTERIES
WARNING
Make sure power to the wheelchair is OFF before performing this procedure.
The use of rubber gloves and chemical goggles or face shield is recommended when working with batteries.
Invacare strongly recommends that battery installation and battery replacement always be done by a qualified technician.
After ANY adjustments, repair or service and BEFORE use, make sure all attaching hardware is tightened securely - otherwise injury or damage may result.
22NF batteries weigh 37 pounds each. GP24 batteries weigh 51 pounds each. Use proper lifting techniques (lift with your legs) to avoid injury.
Failure to use the correct battery size and/or voltage may cause damage to your wheelchair and give you unsatisfactory performance.
ALWAYS use a battery lifting strap when lifting a battery. It is the most convenient method and assures that the battery acid will not spill. It also helps to prolong the life of the battery.
DO NOT tip the batteries. Keep the batteries in an upright position.
NEVER allow any of your tools and/or battery cable(s) to contact BOTH battery post(s) at the same time. An electrical short may occur and serious personal injury or damage may occur.
When tightening the clamps, always use a box wrench. Pliers will “round off” the nuts. NEVER wiggle the battery terminal(s)/post(s) when tightening. The battery may become damaged.
The POSITIVE (+) RED battery cable MUST connect to the POSITIVE (+) battery terminal(s)/post(s), otherwise serious damage will occur to the electrical system.
The warranty and performance specifications contained in this manual are based on the use of deep cycle gel cell batteries. Invacare strongly recommends their use as the power source for this unit.
NOTE: If there is battery acid in the bottom of the battery tray or on the sides of the battery(ies), apply baking soda to these areas to neutralize the battery acid. Before reinstalling the NEW or existing battery(ies), clean the baking soda from the battery tray or battery(ies).
3G Storm Series® Wheelchairs | 56 | Part No. 1104849 |
