B-7

B-7

OPERATION

Return to Section TOC

6.OIL PRESSURE LIGHT: Remains off

with proper oil pressure. If light turns on, the engine protection system will

stop the engine. The light will go on

when the “Engine” switch is switched to the “ON” position with engine not running. It will go off after one minute if the engine is not started.

7. WATER TEMPERATURE LIGHT: Remains off under normal operating temperatures. If light turns on, the engine protection system will stop the

engine. The light will remain on when the engine is over temperature and the “Engine” switch is in the “ON” position (engine not running).

BEFORE STARTING THE ENGINE

Check and fill the engine oil level:

1. Be sure the machine is on a level surface.

2.Remove the engine oil dipstick and wipe it with a clean cloth. Reinsert the dipstick and check the level on the dipstick. See Figure D.1 in the Maintenance section of this manual.

3.Add oil (if necessary) to bring the level up to the full mark. Do not overfill.

Replace the dipstick.

Check and fill the engine fuel tank:

Return to Section TOC

Return to Section TOC

Return to Section TOC

Return to Master TOC

Return to Master TOC

Return to Master TOC

Return to Master TOC

WARNING

HOT COOLANT can burn skin.

Do not remove cap if radiator is hot.

8.FUEL LEVEL GAUGE: Displays the level of diesel fuel in the 10-gallon fuel tank.

9.ENGINE ON-OFF SWITCH: Energizes the fuel solenoid in the ON position. In the STOP position, stops fuel flow to the injection pump and stops the engine.

ENGINE OPERATION

WARNING

DO NOT RUN THE ENGINE AT EXCESSIVE SPEEDS. The maximum allowable high idle speed for the RANGER 10-LX is 3750 RPM, no load. Do NOT adjust the governor screw on the engine. Severe personal injury and damage to the machine can result if it is operated at speeds above the maximum rated speed.

Read and understand all safety instructions included in the Kubota instruction manual that is shipped with your RANGER 10-LX.

Refer to Pre-Operation Engine Service in the Installation section of this manual.

WARNING

DIESEL fuel can cause fire or explosion.

• Stop engine when fueling.

Do not smoke when fueling.

Remove cap slowly to release pressure.

Do not overfill tank.

Wipe up spilled fuel and allow fumes to clear before starting engine.

Keep sparks and flame away from tank.

1.Remove the fuel tank cap.

2.Fill the tank approximately 4 inches (100 mm) from the top of the filler neck to allow for fuel expansion (observe the fuel gauge). DO NOT FILL THE TANK TO THE POINT OF OVERFLOW.

3.Replace the fuel tank cap and tighten securely.

NOTE: DO NOT allow the RANGER 10-LX to run out of fuel. If it does, you will have to bleed the injection system.

NOTE: USE DIESEL FUEL ONLY.

NOTE: Purchase diesel fuel in quantities that will be used within 30 days, to assure freshness.

RANGER 10-LX

Page 21
Image 21
Lincoln Electric SVM120-A service manual Engine Operation, OIL Pressure Light Remains off, HOT Coolant can burn skin