Physical Data 050-061 Models | York YPAL 060, YPAL 061, YPAL 050

FORM 100.50-NOM6 (1207)

PHYSICAL DATA

TABLE 2-5 – PHYSICAL DATA – 050-061 MODELS

		UNIT SIZE	050	051	060	061
	GENERAL DATA
		LENGTH WITHOUT HOOD (INCHES)	339	339	339	339
		WIDTH (INCHES)	92	92	92	92
		HEIGHT (INCHES)	82	82	82	82
		UNIT EER/ IPLV	10.3 / 10.9	10.2 / 10.6	10.1 / 10.4	10.1 / 10.3
		UNIT EER/ IPLV	10.3 / 10.9	10.2 / 10.6	10.1 / 10.4	10.1 / 10.3		2
		UNIT EER/ IPV GAS HEAT						2
		UNIT EER/ IPV GAS HEAT
	COMPRESSOR DATA (SEE TABLE 2-6)

		QUANTITY	4	4	4	4
		TYPE	SCROLL	SCROLL	SCROLL	SCROLL
		UNIT CAPACITY STEPS	4	4	4	4
	REFRIGERANT (410A)
		SYSTEM 1	50 lbs - 0 oz	50 lbs - 0 oz	58 lbs - 11 oz	58 lbs - 11 oz
		SYSTEM 2	50 lbs - 0 oz	50 lbs - 0 oz	58 lbs - 11 oz	58 lbs - 11 ozs
	SUPPLY FAN
		QUANTITY	1	1	1	1
		TYPE	FC	FC	FC	FC
		SIZE	28 - 28	28 - 28	28 - 28	28 - 28
		MOTOR SIZE RANGE (HP)	10 - 40	10 - 40	10 - 40	10 - 40
		AIR FLOW RANGE (CFM) COOLING MIN.	10,000 - 22,500	10,000 - 22,500	12,500 - 24,000	10,000 - 24,000
		STATIC PRESSURE RANGE (TOTAL)	1.0” - 6.0”	1.0” - 6.0”	1.0” - 6.0”	1.0” - 6.0”
	OPTIONAL SUPPLY FAN
		QUANTITY	1	1	1	1
		TYPE	AF	AF	AF	AF
		SIZE	28	28	28	28
		MOTOR SIZE RANGE (HP)	10 - 40	10 - 40	10 - 40	10 - 40
		AIR FLOW RANGE (CFM) COOLING MIN.	10,000 - 22,500	10,000 - 22,500	10,000 - 24,000	10,000 - 24,000
		STATIC PRESSURE RANGE (TOTAL)	1.0” - 8.0”	1.0” - 8.0”	1.0” - 8.0”	1.0” - 8.0”
	EXHAUST FAN
		QUANTITY FANS/MOTORS	2 / 1	2 / 1	2 / 1	2 / 1
		TYPE	FC	FC	FC	FC
		SIZE	18 - 18	18 - 18	18 - 18	18 - 18
		MOTOR SIZE RANGE (HP)	5 - 20	5 - 20	5 - 20	5 - 20
		AIR FLOW RANGE (CFM)	4,000 - 22,500	4,000 - 22,500	4,000 - 24,000	4,000 - 24,000
		STATIC PRESSURE RANGE (TOTAL)	0.1” - 1.5”	0.1” - 1.5”	0.1” - 1.5”	0.1” - 1.5”
	EVAPORATOR COIL
		SIZE (SQUARE FEET)	52	52	52	52
		ROWS/FPI	3 / 17	3 / 17	4 / 17	4 / 17
	CONDENSER COIL
		SIZE (SQUARE FEET)	88	88	88	88
		ROWS/FPI	2 / 17	2 / 17	3 / 17	3 / 17
	CONDENSER FANS
		QUANTITY	4	4	4	4
		TYPE	PROP.	PROP.	PROP.	PROP.
		DIAMETER (INCHES)	36	36	36	36
		MOTOR HP	2	2	2	2

	FILTERS - 2” THROWAWAY (PRE-FILTER POSITION)
		QUANTITY	8 / 12	8 / 12	8 / 12	8 / 12

		SIZE (LENGTH X WIDTH) (IN.)	25X16 / 25X20	25X16 / 25X20	25X16 / 25X20	25X16 / 25X20
		TOTAL FILTER FACE AREA (SQUARE FEET)	61.6	61.6	61.6	61.6
	FILTERS - 2” CLEANABLE (PRE-FILTER POSITION)

		QUANTITY	8 / 12	8 / 12	8 / 12	8 / 12

		SIZE (LENGTH X WIDTH) (IN.)	25X16 / 25X20	25X16 / 25X20	25X16 / 25X20	25X16 / 25X20
		TOTAL FILTER FACE AREA (SQUARE FEET)	63.9	63.9	63.9	63.9

JOHNSON CONTROLS

23

Image 23

York YPAL 060, YPAL 061, YPAL 050, YPAL 051 manual Physical Data 050-061 Models

Contents

Design Level F Simplicity Elite Control INSTALLATION, Operation & MaintenancePackaged Rooftop AIR Conditioning Units Safety Symbols General Safety Guidelines Base Model Number Changeability of this DocumentNomenclature Table of Contents Sound and Vibration Transmission Field Control Wiring ConnectionsChecking the System Prior to Initial Start no Power Transducer Pneumatic Tubing GAS Heat Models Sequence of Operation Ventilation LOW Ambient Minimum Position Reset Excessive SAT Supply AIR Temperature Control 104 154 19 Pipe Sizes List of Tables Packaged Rooftop AIR Conditioning Unit List of Figures Introduction Heating Section Introduction Indoor AIR Quality AIR ManagementControls Electrical Service and Installation Installation Unit Clearances Location Lifting LUG Locations Unit Rigging Unit Center of Gravity Unit WeightsUnit Weights 050-061 Models Unit Corner Weights 050-061 Models Unit Placement Roof Curb Installation Physical Data 050-061 Models Physical Data Physical Data Compressors Bottom Supply / Bottom GeneralArrangement Drawing Arrangement Bottom Supply / Side Return ArrangementGeneral Arrangement Drawing Bottom Supply / Rear Return Arrangement Drawing Supply Return Curb Layout Drawing / 050-061 Models Load Deﬁnitions Electrical Service SizingPower Supply Voltage Limits Electrical Data Electric Data Electric Data Condensate Drain Piping Space Sensor ThermostatFan input Shutdown Input Fault OutputCO2 Sensor Occupied / Unoccupied Input Communication Supply Air Temperature ResetDirty Filter Switch VAV Heat Relay Output Light Field Control Wiring Connections Minimum CircuitAmpacity MCA is based on 125% Power WiringPower Wiring Overcurrent Protection Device Data is supplied on SINGLE-POINT Power Supply Wiring SINGLE-POINT Power Supply Wiring Line Earth Ground 11 DUAL-POINT Power Supply Wiring DUAL-POINT Power Supply Wiring Supply Single Point Dual Point TB Voltage Disconnect Controls Building Pressure Transducer Static Pressure Probe InstallationStatic Pressure Control Plastic Tubing Pneumatic Tubing Duct Static Transducer Filter Compartment Economizer Duct Connection Guidelines 17 Supply AIR Duct Connection Configurations18 Return AIR Duct Connection Configurations Unit Configuration 19 Pipe Sizes GAS HeatingGas Piping Recommendations GAS Piping 14 Combustion Vent Combustion Vent Crankcase Heaters START-UPUnit Checks Startup Compressor Oil Level Check Unit Checks Power AppliedVerifying Compressor Rotation Superheat R-410A Refrigerant ChargeChecking Superheat and Subcooling Subcooling R-410A Leak Checking Psig Temp ˚F R410-A Pressure / Temperature Chart GAS Heat Models Pre-Start ChecksPost Start Checks GAS LOW Fire / High Fire PressuresGAS Heat Performance Data Type Line Pressure Manifold Pressure Maintenance Entire Unit Inspection Condenser CoilsMotor Bearing Lubrication Belt Tension Belt Tensioning Belt Replacement Forward Curved Fans Filter Drier Replacement Mounting Details Fan MotorFan Shaft Bearings Bearing Lock Devices Eccentric Type Torquing of Set-screws This page Intentionally Left Blank Unit Type Occupied / Unoccupied ModeConstant Volume Mode CV Sequence of Operation Unoccupied Cooling Heating Mode Enabled for OperationThermostat Input Occupied Cooling Cooling Operation Occupied or Unoccupied Space Sensor Hard Wired or CommunicatedOccupied Heating Unoccupied Heating Stand Alone Heating Operation Occupied or Unoccupied Simplicity Control will stage off the cooling as follows Cooling Supply AIR Temp Lower Setpoint Variable AIR Volume VAVCooling Occupied with Thermostat Occupied or Unoccupied Heating with a Thermo- stat Cooling Unoccupied with Thermostat Morning Warm UP RAT Setpoint VAV Occupied Heating SetpointMorning Warm UP / VAV Return AIR Temp Setpoint Occupied Cooling Stand Alone VAV Supplyair Temp Reset Setpoint Sequence of Operation Cooling Unoccupied Stand AloneHeating Occupied Stand Alone Heating Unoccupied Stand Alone Conﬁguration Jumpers and Potentiometers Operation and Pressure Control Range Supply FAN Operation Constant Volume CV Variable Air Volume VAV Able Setpoint VAV Supply Fan Speed ControlDuct Pressure Shutdown Setpoint Dry Bulb Dual Enthalpy Outside AIR Humidity Sensor InstalledReturn AIR Humidity Sensor Installed Single Enthalpy Variable Air Volume Economizer Set Point Constant Volume Economizer Set Point Economizer Loading Economizer / Compressor OperationEconomizer PI Loop Proportional and Integral Variable Air Volume Constant Volume Operation During OFF Cycle Compressor on When Space Input SatisfiedComfort Ventilation Supply AIR Temp Limit Cooling Setpoint Tion Upper SetpointConditions of Operation Cooling Supply AIR Temp Limit Heating Setpoint Heating Space Sensor with SET Point Adjustment Redline Space Sensor Fault Override EnableRemote Control INTELLI-START LoadshedDirty Filter Metric Operation Subsequent Operation First day of heating or cooling operation Morning WARM-UP ING WARM-UP/VAV Return AIR Temp Setpoint Ventilation Hydronic HeatHydronic Heat Freeze Stat Demand Ventilation ManualFixed Minimum Deﬁnitions Ventilation LOW Ambient Minimum Position Reset Exhaust FAN Operation On/Off Control Based on Outdoor Damper Posi- tionOn/Off Control Based on Building Pressure Modulating Exhaust with a VFD Modulating Damper with Fixed Speed Exhaust PRE-OCCUPANCY Purge Criteria for Operation Outdoor AIR Heating Lockout Energy Recovery VentilatorSpace Temperature Alarm LOW Voltage Protection SAT Alarm for Heating SAT Alarm for Cooling Economizer Minimum Position AlarmSupply AIR Temp Alarm Setpoint for Heating Alarm History Supply AIR Temp Alarm Setpoint for Cooling Program Button User InterfaceUnit Controller Interface Character Display Addresses & Codes ALARM/CHANGETEST/UP Button ADDRESS/DOWN Button Parameter Points List 102 103 Simplicity PC Download Left click on software USB Adapter Drive Simplicity Pocket PC Establishing Communication Cable Wire Color Adapter Terminal Board Marking 108 Left-click on the particular Simplicity device de- sired 110 Device Names Equipment InstallationSimplicity PC Data Screens Sensor Readings ECONOMIZER/EXHAUST Fans Cooling Setup Cooling Status Heating Setup Heating Status System Options OUTPUTS/STATUS COMFORT/DEMAND Ventilation Inputs Graphic Weekly Schedule Weekly Schedule Settings Holiday Schedule Holiday Schedule Alarms Revising Settings 127 128 129 HEX Initial Address BIT DefaultSimplicity Elite Data MAP HEX DEC Value Description HEX DEC Value 132 133 134 135 136 137 138 139 140 Definitions Parameter Descriptions and Options Parameter Description and Options 143 144 145 146 147 148 149 150 151 152 Analog Input Operation ServiceTemperature Sensors Temperature Sensor Resistance Return FAN Pressure Transducer Output Return Fan Pressure TransducerDischarge Pressure Transducer Duct Pressure Transducer Humidity Sensor Outputs Suction Pressure TransducerHumidity Sensors Pressure Transducers PPM CO2 Output Furnace Status InputCO2 Sensor Output Connector # Type Identification Wire # Description Connector Locations Wiring Data 158 159 Light Emitting Diode Alarm Codes Faults and Lockouts Alarm Code Description Alarm Code Descriptions 162 Alarm Trouble Shooting Space Temperature Sensor Alarm Low Pressure Cutout Alarm 09, 10, 11Limit Switch Alarms 13, 14 Gas Heating Alarms 16, 17 Dirty Filter Switch Alarm Supply Air Temperature Sensor AlarmReturn Air Temperature Sensor Alarm Outdoor Air Temperature Sensor Alarm Time Clock Error Alarm Outdoor Humidity Sensor AlarmReturn Humidity Sensor Alarm IAQ CO2 Sensor Alarm Duct Static Low Pressure Alarm Supply Air Temperature Cooling AlarmSupply Air Temperature Heating Alarm Space Temperature Trending Alarm ALL Rights Reserved